Professional Documents
Culture Documents
Bizhub 185 165 Installation Manual
Bizhub 185 165 Installation Manual
Bizhub 185 165 Installation Manual
INSTALLATION MANUAL
Applied Machines: /
7. CD-ROM* 1 set
* Varies depending on the applicable marketing
area.
A0XXIXC008DA
E-2
4. Unscrew the screws shown in the illustration to 9. Slide out the drawer and remove the developer
remove the imaging unit (two screws). and cushioning material.
Note:
• Do not touch or scratch the photo conductor.
• Cover the imaging unit, which has been Developer
removed, with a protective cloth or similar
material.
A0XXIXC006MA
A0XXIXC012MA
A0XXIXC009DA
E-3
VII. Loading the Developer 3. Remove the developing unit cover (three
screws).
1. While pressing the connector tabs, push out the
connector from the imaging unit.
A11UIXC014MA
Tabs A0XXIXC040MA
4. Ready a packet of the developer and cut off one
corner of the aluminum packet with scissors.
2. Unscrew the screws that secure the drum unit, 5. While turning the gear in the direction of the
and then take out the drum unit by slightly open- arrow, pour the developer evenly into the devel-
ing the lower part (the shadowed area) of the oper chamber.
drum unit (five screws).
Note:
Note: • Turn the magnet roller in the direction of its nor-
• Do not open the lower part wide, otherwise the mal rotation, and not the backward.
charger may drop. • Be sure not to let the developer get inside the
• Do not touch or scratch the photo conductor. collar.
• Cover the drum unit, which has been removed,
with a protective cloth or similar material. Collar
Drum unit
A11UIXC015MA
A0XXIXC013MA
A11UIXC016MA
E-4
7. Install the front of the drum unit first, and then the 10. Plug the connector, and then attach the cover
rear part. Then, secure the screws (five screws). (one screw).
Note:
• Do not open the lower part wide, otherwise the
charger may drop.
• Clean the screw groove before securing them.
• Do not touch or scratch the photo conductor.
8. Attach the imaging unit connector that is removed
in step 1.
A0XXIXC008DA
A0XXIXC019MA
E-5
IX. Installing the Toner Bottle
Note:
A toner bottle may not be shipped with your
machine. If not, purchase one that is separately
available.
1. Shake the toner bottle well about five times in the
vertical direction. Then, turn it over and repeat
the same procedure.
Note:
The toner can cake in the toner bottle. Be sure to
perform this procedure.
2. Open the front door.
3. Insert the toner bottle halfway with the tape side
up, and then slowly peel the tape off the bottle.
Tape
A0XXIXC018MA
A0XXIXC050MA
E-6