Professional Documents
Culture Documents
A SME
A SME
A SME
Term Definition
When mating flanges, the maximum amount of 1/16" per foot
unparallel allowed (per diameter of flange in feet)
is
Answer found
Term Definition
On flange what is the maximum offset for bolt
On a flange the maximum bolt hole offset
holes for mating flanges is 1/8" when mating
Answer found
Term Definition
What is the distance of the Preheat-Zone from
The the
Preheat zone shall extent at least 1" beyond
toe of the weld each edge of the weld
Answer found
Term Definition
What is the distance of the PWHT zone from
1" isthe
the distance of the PWHT zone from the toe
toe of the weld of the weld
Answer found
Term Definition
When performing NDE inspection what is the
minimum length of spot RT
when performing spot RT a min of 6" shall be
examined
Term Definition
The NDE maximum length of a crack, incomplete 0"
fusion allowed in a new weld is
Term Definition
When useing multiple heats for PWHT the Min overlap is 12" for PWHT
minimum overlap is
Term Definition
When performing NDE, whats the number of 2
additional welds or joints to examine when a
defect is found during a random examination
B31.3: 341.3.4.a
Term Definition
When perforning a Impact Test , what is the # of 3
test bars required in each set
B31.3: 323.3.3
Term Definition
Whats the # of Stress Cycles needed to become 7000
rated as Severe Cyclic Stress
B31.3: 300.2
Term Definition
Answer found in
Term Definition
Term Definition
Term Definition
Term Definition
As per ASME B31.3 the recommended minimum
If the ambient temperature is below 32°F
preheat temps are required when
B31.3 330.1.1
Term Definition
The PWHT temperature for Carbon Steel are 1100-1200°F
Term Definition
Whats the minimum duration for a pressure test 10 min
B31.3: 345.2.2.a
Term Definition
Whats the Minimum years of experience for 10 years
Owner's Inspector during new fabrication
B31.3: 340.4.b