Professional Documents
Culture Documents
API 653 - 575 Flash Cards - 27 Questions PDF
API 653 - 575 Flash Cards - 27 Questions PDF
Strength (4.2.3)
Corrosion (5.2)
8. A tank that is supported above grade on a ring wall has its bottom exposed to
the elements. As an inspector, what would you do to prevent possible bottom
corrosion?
11. If the pan-type (single-deck) floating roof has a plugged water draw-off, what
would be the most likely consequence?
API 653
13. An AST was built and put in-service in 1990. The minimum thickness of the
bottom course was 0.35". The bottom course was constructed using 0.5" thick
plates. The tank was not inspected again until 2006. Thickness of the bottom
course was measured at 0.42". Determine the corrosion rate and calculated
remaining life.
14. What type of inspection provides another means of establishing suitability for
continued service?
16. Why should inspectors exercise great care when inspecting a roof of an
insulated tank?
Thin roof might not be strong enough to support weight of inspector (7.2.7)
17. Coatings (paint, etc.) may affect UT readings. What should be done?
18. A storage tank is used to store a product that must be kept warm (150ºF+). The
product has a high concentration of caustic and stress-corrosion cracking is
suspected because of caustic embrittlement. Where would you look for cracks?
By tapping the rivet or bolt head laterally with a hammer while holding the
opposite side (7.2.8.6)
20. If a fixed cone roof of a tank is suspected of being extremely thin, what
precaution should an inspector take to facilitate his inspection (beside using safety
harness with lanyard to tie-off point)?
Use planks long enough to extend over two roof rafters or walk on weld
seams (7.2.9)
22. When statistical methods are used for assessing the probable condition of a
tank bottom, what controls the number of UT measurements taken?
23. What size coupon is recommended for removal from a tank bottom to check
for underside corrosion?
24. When penetrating oil is sprayed on the outside shell-to-bottom weld for a test,
what is this test called?
25. What is a method for checking for weld leaks in the bottom and in the shell?