The document outlines requirements to be added to the Piping ITP, including covering PED 2014-68-EU standards, adding details on pipe supports, PMIs, pig launchers/receivers, PWHT, heat tracing, reinforcing pads, insulation, coating adhesion testing, tightness testing, hydrotesting, and specifying relevant documents in the ITP columns.
The document outlines requirements to be added to the Piping ITP, including covering PED 2014-68-EU standards, adding details on pipe supports, PMIs, pig launchers/receivers, PWHT, heat tracing, reinforcing pads, insulation, coating adhesion testing, tightness testing, hydrotesting, and specifying relevant documents in the ITP columns.
The document outlines requirements to be added to the Piping ITP, including covering PED 2014-68-EU standards, adding details on pipe supports, PMIs, pig launchers/receivers, PWHT, heat tracing, reinforcing pads, insulation, coating adhesion testing, tightness testing, hydrotesting, and specifying relevant documents in the ITP columns.
PED 2014-68-EU requirements must be covered (293902-GEN-PIP-
SP-50007 Rev 2 Piping Material Specification and Line Classes / 293902-LAM-PIP-SP-50006 Rev 1 General Specification for Design and Fabrication of Piping Systems) Pipe supports (293902-LAM-PIP-PS-50051) PMIs Pig launchers / Receivers PWHT Heat tracing Reinforcing pads Insulation (293902-LAM-PIP-SP-50009 Insulation) Coating -> adhesion test (2939023-LAM-MAT-SP-68020 Top side painting) Tightness test Hydro-test – flushing procedure to be submitted to ENERGEAN for review In ITP columns Reference Doc., Acceptance reference criteria, Quality Control Forms, specify the relevant documents.