Professional Documents
Culture Documents
M4 SD Ii Manual
M4 SD Ii Manual
M4 SD Ii Manual
device after every use to ensure mating surfaces are free of copper
and carbon fouling. Failure to clean the mounting system can result
in your M4-SD II becoming stuck to the muzzle device on your
weapon. No other maintenance is required with this silencer. If the
silencer for whatever reason becomes filled with water, shake out
TM- M4SD II
excess water in the direction of the rear mount and store unit muzzle
up to dry, or bake at 300F for an hour to dry at the earliest
Sound Suppressor
convenience. An Oatey No. 31328, 3/4 In. Heavy-Duty Inside
Diameter Fitting Brush can be used to clean the mount surfaces inside
the suppressor. This brush is available for $2.20 currently at Home
Depot in the plumbing department, and can be purchased online from
other retailers. The brush has carbon steel bristles so residue left on
the 17-4PH Stainless mount by the brush may give the appearance of
very light rust- Application of Hoppes number 9 or some other
cleaner/protectant to the mounting bore between uses will prevent that
as well as help to loosen copper fouling. The carbon steel bristles
have higher strength necessary to easily remove copper fouling.
Make sure you clean both the rear mounting interface and front flash
hider support as this is a second bearing surface for the flash
suppressor.
Finish: Operation at temperatures exceeding 1100F after firing more
than 100 rounds in 1-3 minutes, may damage the finish which is
Norrell Moly coating and has a minimum thermal breakaway of
1000F. If refinishing is desired, rub the old loosened, heat affected
coating off with rubbing alcohol and a clean rag and apply the finish
of your choice. We recommend Norrell Moly, or 1200F matte black
grill paint. Use a light coat with the locking gate down and silencer
standing on the rear cap. Painting the mount bore, locking gate, or
locking gate pocket may result in tolerance interference, rendering the
unit inoperable till interfering coating thickness is removed.
CAUTION: The M4-SD Silencer confronts the Impulse noise at the
muzzle of your weapon and cannot account for the action’s associated
operating noise which will vary by weapon type and barrel length.
For the highest level of hearing protection, wear hearing protection at
WARNING: FAILURE TO READ AND UNDERSTAND THIS MANUAL
all times while using your silencer. PRIOR TO USE MAY RESULT IN INJURY OR DAMAGE TO
PROPERTY
Page 2 Page 3