Professional Documents
Culture Documents
TP Mem 18-19
TP Mem 18-19
CO UO Actual
Plan
Execution
Chapter No. (Mention (Mention
Titles/ Details* (from To Teaching Method/Media Remarks
only Only (from To
(Allocated Hrs.) & No of
Number) Number) & No of
lectures)
lectures)
a 1a 1.1.Introduction,Types of
measurement, classification of Mechanical Measurement and
instruments, Static terms and Instrumentation and controls by A.K
characteristics- Range and Span, SAWHNEY Page no.1 to 10, .
Accuracy and Precision
1.Introduction to a 1a 1.2.Reliability, Calibration,
Measurement Hysteresis and Dead zone, Drift, Mechanical Measurement and
(6 hours) Sensitivity, Threshold and Instrumentation and controls by A.K
Resolution, Repeatability and SAWHNEY Page no.28 to 47, CIS.
Reproducibility, Linearity
a 1b 1.3. Dynamic characteristics- Mechanical Measurement and
Speed of response, Fidelity and Instrumentation and controls by A.K
Dynamic errors, Overshoot SAWHNEY Page no.1 to 10, CIS.
a 1d
Mechanical Measurement and
1.6.contact type, non-contact type
Instrumentation and controls by A.K
& REVISION SAWHNEY Page no.265 to 306,
b 2a
2.1.Capacitive transducer, Mechanical Measurement and
Potentiometer, LVDT, RVDT, Instrumentation and controls by A.K
Specification SAWHNEY Page no.253 to 259
b
2.10 SIT-1
c
3.8. SIT-1 .
d 4a
Mechanical Measurement and
4.1 Types of Flow meter,
Instrumentation and controls by A.K
selection criteria & classification SAWHNEY Page no.715 to 717.
d
4.7. REVISION
f
6.7 SIT-2
e 5a
5.1 Concept of natural frequency,
Self Notes, CIS
FBD & spring mass system
e 5b
5. Vibration & 5.2 Vibration measurement system Self Notes, CIS
Strain
measurement e 5c
(8 hours) 5.3 Introduction to FFT analyzer,
Self Notes, CIS
working & application
5.6 Revision