Professional Documents
Culture Documents
Calculating LD 50 LC 50 PROBIT ANALYSIS IN EXCEL
Calculating LD 50 LC 50 PROBIT ANALYSIS IN EXCEL
Calculating LD 50 LC 50 PROBIT ANALYSIS IN EXCEL
Latest version uploaded on 19 April 2017 (Can cater for 100 dose-response groups)
(Please Note:
1. This calculator is based on the method of Finney (1952). [D.J.Finney (1952) Probit Analysis
(2nd Ed), Journal of the Institute of Actuaries, 78 (3): 388-390]
2. This calculator works with Excel 2010 or higher. There are issues with lower versions due to
array formulas.)
Median lethal dose or concentration is the dose or concentration of the compound that produces 50%
mortality in the exposed population. Estimation of LD or LC provides a measure of acute toxicity of
the compound and is used for comparing the toxicities of two compounds.
The LD or LC values are calculated using ‘Probit Analysis’, which was initially developed by D.J.
Finney (1971) and later discussed in detail elsewhere (Finney, 1978; Robertson et al., 2007). In general,
the data from bioassays ( mortality proportions and corresponding doses) gives an S-shape curve. In
order to make this curve linear, the proportions are transformed to probits and doses to log10. The
LD or LC values are estimated using regression analysis (Busvine 1971).
https://probitanalysis.wordpress.com/ 1/4
09/12/2017 Calculating LD50/LC50 using Probit Analysis in EXCEL
Several computer programmes (SAS, SPSS,POLO, LeOra etc) accurately calculate LD or LC values
but these programmes are not free and require knowledge of using them. Furthermore, these
programmes do not provide real-time results (time is required for entering commands and
processing). Hence, in this blog an user-friendly, free, dynamic EXCEL spreadsheet is provided for
estimating LD or LC values.
The following steps are used in the calculation of LD or LC in this spread sheet
3. The proportions are corrected for control mortality if its is more than 10% using Schneider-Orelli’s
(1947) formula:
5. A dose response curve is drawn using the log(10) doses (x) and empirical probits (y) and the
regression equation is derived. Empirical probits less than 1 and more than 7 are ignored as they have
li le and no significance in the estimation of LD or LC (Hayes, 2014).
y=5+(x-µ)/σ
6. From the equation of the curve and log10 doses, the expected probits (Yi) are derived
7. From the expected probits (Yi), expected mortality proportion followed by expected no.of animals
are derived
8. The original mortality (Observed) and derived mortality (Expected) are used to calculate the Chi-
Square test with (No. of log doses used -2) degrees of freedom. If the Chi-square test is non-
significant, it indicates good curve fi ing.
Z=1/(√2π)e(-1/2(Yi-5)^2)
W=Z^(2 )/PQ,
Q=(1-P)
10. The weighted coefficients were used to calculate the standard error
SE= σ/√ƩnW
https://probitanalysis.wordpress.com/ 2/4
09/12/2017 Calculating LD50/LC50 using Probit Analysis in EXCEL
W= Weighting coefficient
11. Working probits (Yw) are derived from the regression equation as follows
Yw = Yi-(P/Z)-p/Z
Y = Expected probits
P = Expected Proportion
p = Observed proportion
11. The LD or LC values are derived from the curve drawn using working probits and log doses.
Antilog of the dose corresponding to respective probit value.
12. 95% Fiducial confidence limits are calculated using the formula
(Your comments and corrections are welcome to make this spread sheet be er:
alpharajm@gmail.com)
Busvine J.r. 1971. A critical review of the techniques for testing insecticides. Commonwealth
Agricultural
Finney, D. J., Ed. (1952). Probit Analysis. Cambridge, England, Cambridge University Press.
Finney, D. J. and W. L. Stevens (1948). “A table for the calculation of working probits and weights in
probit analysis.” Biometrika 35(1-2): 191-201.
https://probitanalysis.wordpress.com/ 3/4
09/12/2017 Calculating LD50/LC50 using Probit Analysis in EXCEL
Advertisements
alpharajm
July 7, 2016April 19, 2017
https://probitanalysis.wordpress.com/ 4/4