Professional Documents
Culture Documents
Test
Test
Test
Q.No.09 Some fixed pitch propeller designs have their balance adjusted by
A- Placing lead wool in balance holes only
B- attached weight to the side of the hub only
Propellers
M-17 Grand Test Time: 40Min Code: MVGT11MY
C- Placing lead wool in balance holes and attached weight to the side of the
hub
Q.No.11 What are the rotational speed and blade pitch angle requirements of a
constant-speed propeller for take-off and cruise .
A- High speed with low pitch angle for take-off and low speed with high
blade angle for cruise.
B- High speed with high pitch angle for take-off and low speed with high
blade angle for cruise.
C- High speed with low pitch angle for take-off and high speed with high
blade angle for cruise.
Q.No.12 When the power is increase, the constant-speed propeller tries to function, so
that it will
A- Maintain the RPM, increase the blade angle
B- Maintain the RPM, decrease the blade angle
C- increase the RPM, maintain the blade angle
Q.No.13 When governor flyweights is less than governor spring load, the CSU is
A- Overspeed and slide valve moves upwords
B- Underspeed and slide valve moves downwords
C- Underspeed and slide valve moves upwords
Q.No.18 Dye should be added in fluid for __________Testing and fluid delivery rate
checking for ______
A- for coloring testing, Pump testing
B- for flow testing , Pump testing
C- for functional testing , flow test
Q.No.19 Continuity Resistance test is used ___ and Insulation test is used ____
A- for heater element , for breakdown between heater element and blades.
B- for heater element , for breakdown between brush gear and slip ring.
C- for brush gear , for breakdown between heater element and blades.
Q.No.20 What unit in the propeller anti-icing and de-iceing system controls the
output?
A- Rheostat for anti-iceing and cycling timer for de-iceing
B- cycling timer for anti-iceing and Rheostat for de-iceing
Q.No.22. Insulation/resistance checks are carried out to find any breakdown between:
a relays and control circuits
b heater element and blade
c propeller blades and the hub
Q.No.23. What is used to give the signal for operating the synchronising system?
a blade pick up points
b control alternator
c pick up points
Q.No.27. A slinger ring mounted on the rear of the propeller hub holds fluid in its
curved channel by:
a back pressure
b centripetal force
c centrifugal force
Q.No.28. If a fluid anti-icing system is not going to be used for a long period, the system
should be drained and refilled with:
a 95% methyl ethyl ketone and 5% distilled water
b 95% methylated spirits and 5% distilled water
c 55% methylated spirits and 5% mineral water
Q.No.31. In the McCauley single acting propeller, oil takes the propeller into:
a feather
b fine pitch
c coarse pitch