Professional Documents
Culture Documents
Waterstop Installation Instructions
Waterstop Installation Instructions
Preparation:
1. Before installation, uncoil waterstops (leave open to reduce shape-memory), this will allow
the waterstop to resume straight shape for easier handling.
2. Check the waterstop for any defects or cracks. Replace any defective areas.
Installation:
1. Place waterstops at appropriate position. Make sure that half of the waterstop width is
embedded in the concrete before pouring.
2. Maintain approximately 1.5 times of clear coverage between the waterstop and reinforced
steel making sure that there are no rock pockets or air voids.
3. Tie the waterstop to surrounding reinforcing steels by threading steel wire to metal eyelets,
punched holes or hot rings to waterstops to fix the waterstop firmly. Make sure there is no
displacement during fastening.
4. Pour and vibrate the concrete, especially near the joints under the waterstop (this will
enhance the concrete contact with the waterstops).
5. Clean debris and dirt from concrete surface after the first pour.