Professional Documents
Culture Documents
2019/1/10: ميلستلا دعوم PROBLEM #1: For the connection shown below, Assume A36 steel for the plates (f
2019/1/10: ميلستلا دعوم PROBLEM #1: For the connection shown below, Assume A36 steel for the plates (f
2019/1/10: ميلستلا دعوم PROBLEM #1: For the connection shown below, Assume A36 steel for the plates (f
PROBLEM #1: For the connection shown below, Assume A36 steel for the plates (fy =250 MPa
& fu= 400 MPa) and A572 G50 plates (fy =345 MPa & fu= 450 MPa) for the UPN tension member, if
M16 A325-N bolts in standard holes were used; compute the tensile strength for the connection
based on bearing and shear only (for A325-N bolts, Fnv=330 MPa).
PL 12 X 280 M16
UPN 220
T 40mm T
40mm
40mm
PROBLEM # 2: Use LRFD to determine the number of M20 mm-diameter A490-X bolts
(𝐹𝑛𝑣 = 520𝑀𝑃𝑎) required, based on shear and bearing, along line a–b in the figure bellow. The
given loads are service loads. A36 Steel is used for both the angles and the gusset plate.
(Assume 𝑆 = 3𝑑𝑏 & 𝐿𝑒 = 1.75𝑑𝑏 when needed).
. ) او ورق مسطر فقطA4( يجب تسليم الواجب في الموعد المحدد للتسليم من قبل أستاذ المقرر كما يجب تسليم الواجب في ورق ابيض: مالحظة هامة