Professional Documents
Culture Documents
Amplitude Modulation
Amplitude Modulation
1 – AMPLITUDE MODULATION
OBJECTIVES:
The purpose of this experiment is to examine the AM signal using the scope and compare it to the
original signal, and to observe the effects of modulating the carrier too much.
Materials:
1. Personal Computer with necessary software installed
2. NI ELVIS II plus USB cable and power pack
3. Emona DATEx experimental add-in module
4. Two (2) BNC to 2mm banana-plug leads
5. Assorted 2mm Banana-plug patch leads
Procedures:
1. Ensure that the NI ELVIS II power switch at the back of the unit is off.
2. Carefully plug the Emona DATEx Experimental add-in module into the NI ELVIS II.
3. Connect the set-up shown below.
Analysis
This experiment shows the result of amplitude modulating the carrier with the message. The modulated
carrier’s amplitude varies with the unmodulated amplitude. It also shows that the AM signal’s envelopes
are the same shape as the message.
Conclusion
Villafuerte, Lea