Professional Documents
Culture Documents
TW 4M 1 N
TW 4M 1 N
TW 4M 1 N
on
Output Load resistance 1 to 5 V off 4 to 20 mA on
off
0 to 5 VDC on 1 2 3 4 5 6 7 8
1 to 5 VDC More than 2 KΩ -5 to 5 V off
1 2 3 4 5 6 7 8
-5 to 5 VDC
0 to 10 VDC
-10 to 10 VDC
More than 4 KΩ Ordering Code
TW – 4M – –N
0 to 20 mADC 1. 100 to 240 VAC ±10%
Less than 550 Ω Code to
4 to 20 mADC specify power 4. 24 VDC ±10%
Sliding from 96 to 98
I/O range
3. Temperature characteristic: ±0.02% F.S/°C setting
4. Response time: Less than 50ms (Time required for arriving Dip SWs.
at 90% of rated output) ZERO/SPAN
35.4
35.2
64.5
94
adjusters
5. Insulation resistance: Between input and output or power supply,
More than 100 MΩ (At 500 VDC) I/O range
setting
6. Dielectric strength: Between input and output or power supply, Dip SWs.
For 1 min. (At 2000 VAC)
7. Power supply voltage: 100 to 240 VAC ±10% or 24 VDC ±10%
Consuming current:
Less than 50mA (At 100 VAC) 20
Less than 80mA (At 24 VDC) 4.5
8. Operating ambient temperature: -5 to +50°C
9. Operating humidity: Less than 90% RH (No dew-condensing)
Connection Diagram
10. Storage temperature: -10 to +70°C -
Power
- Power
4 8 100-240VAC
11. Storage humidity: Less than 60% RH (No dew-condensing) Input
signal 50 / 60Hz 24VDC
12. Case material: Black PBT 94-V0
+ 3 7 50mA + 80mA
13. Weight: Approx. 130g 15V
MAX TW-4M
About solderless terminal to connect with 30mA
2 6 -
the screw type terminal block Output 18V
Signal 30mA
MAX
1.Screw size: M3.5×7L 1 5 +
2.Recommendation solderless terminal: Ring tongue (R type) M3.5
Spade tongue (A type) M3.5 ! Note : When conducting wiring, be careful with its polarity.
Applicable Wire AWG# 26 to22
3.Quality of material: Screw Iron, nickel plating
Connection board Block Diagram
Yellow copper, tin plating
Isolation Amp ZERO SPAN
Setting or changing input/output range 3(+) Input 5(+)
! Always set or change the input/output range with the power turned off. Input signal
circuit Output Output signal
4(-) circuit
The input/output range can be set or changed by dip switches SW1 6(-)
and SW2, SW3 on top of the transducer.
Power circuit
7(~), (+)
After finishing the setting, stick the attached seal to the window for dip Power
switch operation. Prior to factory shipment, the input is set 1 to 5 V 8(~), (-)
and the output, 4 to 20 mA.
SW1 SW2 SW3
Range settings on
before shipment off