Professional Documents
Culture Documents
Masterseal 720: General Purpose Polysulphide Joint Sealant
Masterseal 720: General Purpose Polysulphide Joint Sealant
Masterseal 720: General Purpose Polysulphide Joint Sealant
JOINT DEPTH mm
6 55.5 27.8 16.7 13.3 11.1 8.4
MIXING
MasterSeal® 720 is supplied in a 2l kit. The activator 12 27.8 13.9 8.4 6.7 5.5 4.2
is packaged in a plastic bag that rests on top of the 20 16.7 8.4 5.1 4 3.4 2.5
sealant base separated from it by a plastic sheet.
25 13.3 6.7 4 3.2 2.7 2
Remove the plastic separating sheet, transfer the
total quantity of activator onto the base component 40 11.1 5.5 3.4 2.7 2.2 1.7
and mix thoroughly using a slow speed electric drill
fitted with a flat blade stirrer. Scrape down the sides Approx. length of Joint in metres/2.0ℓ unit
of the can and the base and remix until the colour is
uniform and free from streaks. Thorough mixing is PROPERTIES
essential and should take 5 to 10 minutes.
Mixing Ratio Do not split kits
3
Density 1.49g/cm
APPLICATION O
Pot life (at 25 C) >45 Minutes
O
Fill the sealant into a closed barrel gun using a Application Temperature 5-35 C
O O
Service temperature -25 Cto +90 C
follow plate or small trowel. Gun the sealant into the Hardness ±15 Shore A
joint using a continuous squeezing of the trigger to Movement Accommodation 30%
Tack free 2 days
ensure a smooth continuous flow of material. Fill the
Full cure 7 days
joint from the bottom up and ensure that there is Chemical resistance Most dilutedChemical,
contact between the sealant and joint surfaces. To fuel Oils and solvents
The technical information and application advice given in this BASF publication are based on the present state of
STATEMENT OF our best scientific and practical knowledge. As the information herein is of a general nature, no assumption can be
RESPONSIBILITY made as to a product's suitability for a particular use or application and no warranty as to its accuracy, reliability or
completeness either expressed or implied is given other than those required by law. The user is responsible for
checking the suitability of products for their intended use.
Field service where provided does not constitute supervisory responsibility. Suggestions made by
NOTE BASF either orally or in writing may be followed, modified or rejected by the owner, engineer or contractor since
they, and not BASF, are responsible for carrying out procedures appropriate to a specific application.