The document outlines two proposals for changing subway and bus fares in New York City. Proposal 1A would raise the base fare to $2.50 and express bus fare to $6.00 while keeping a 7% bonus for purchases over $10. Proposal 1B is similar but introduces a $1 metrocard purchase fee. Proposal 2A would keep the base fare at $2.25 but raise 30-day passes to $119 and introduce a $1 purchase fee and 5% bonus. Proposal 2B is nearly identical but raises express bus fare to $5.50.
The document outlines two proposals for changing subway and bus fares in New York City. Proposal 1A would raise the base fare to $2.50 and express bus fare to $6.00 while keeping a 7% bonus for purchases over $10. Proposal 1B is similar but introduces a $1 metrocard purchase fee. Proposal 2A would keep the base fare at $2.25 but raise 30-day passes to $119 and introduce a $1 purchase fee and 5% bonus. Proposal 2B is nearly identical but raises express bus fare to $5.50.
The document outlines two proposals for changing subway and bus fares in New York City. Proposal 1A would raise the base fare to $2.50 and express bus fare to $6.00 while keeping a 7% bonus for purchases over $10. Proposal 1B is similar but introduces a $1 metrocard purchase fee. Proposal 2A would keep the base fare at $2.25 but raise 30-day passes to $119 and introduce a $1 purchase fee and 5% bonus. Proposal 2B is nearly identical but raises express bus fare to $5.50.
Here they have a slightly different term on the installation instructions. 1. Install clutch master cylinder (1). 2. Insert tube into master cylinder port and install retaining clip (5). 3. Connect clutch master cylinder supply hose (2) to brake master cylinder reservoir (1). 4. Verify that brake master cylinder reservoir is full and cap is off. 5. Position clutch master cylinder body vertically, with pushrod pointing down, for about ten seconds to purge air trapped from end of cylinder. 6. Install clutch master cylinder body to dash panel and 1/4 turn to secure. 7. Connect clutch master cylinder rod to clutch pedal pin. An audible "click" should be heard. 8. Install lower instrument panel bezel. 9. Connect battery negative cable. 10. Install air cleaner assembly (1). 11. Verify that brake master cylinder reservoir is full. Top off with DOT 3 brake fluid if necessary. 12. Bleed clutch system (More info on this is available too, if needed). 13. Actuate clutch pedal a minimum of fifteen