Professional Documents
Culture Documents
S2 - Floor / Roof: Design of Two - Way Slab With Provision For Torsion at Corners
S2 - Floor / Roof: Design of Two - Way Slab With Provision For Torsion at Corners
2
Self wt. of slab : 3.75 kN/m - Assumed Slab thickness, D = 150 mm
2 3
Floor/roof finishes : 3.20 kN/m (Unit wt. of Conc. = 25 kN/m )
2
Partition walls : 0.00 kN/m
2
Other Services : 0.40 kN/m
2
Total Dead load (DL): 7.35 kN/m
2
Total Live load (LL): 2.00 kN/m
2
Ult. Load (1.4DL+1.6LL): 13.49 kN/m
Slab Analysis :
Ly/Lx = 1.19
- refer Table - 3.14, page - 31
Type of panel : 9 - Four Edges Discontinuous
Page 1 S2
Project : 0.000 Page - 2 of 2
Short steel :
bottom: 17.405 1000 120 460 35 1.21 0.288 346 195 10 @ 125 628
top: 0.000 1000 120 460 35 0.00 0.000 0 195 10 @ 125 628
Long steel :
bottom: 13.326 1000 110 460 35 1.10 0.262 288 195 10 @ 200 393
top: 0.000 1000 110 460 35 0.00 0.000 0 195 10 @ 200 393
Refer section - 3.4.4.4 (page - 20), BS8110.
Deflection Check :
pt reqd. = 0.288 %
2
As,reqd. = 346 mm
2
As,provd. = 628 mm
2
Service stress fs = 169 N/mm ; fs = 2/3 fy (Ast reqd/Ast provd) / bb, where bb = 1.0
2
Modification Factor for Tension MF = 0.55 + (477 - fs)/(120 x [0.9 + Mu/bd ]) - Limited to 2.0
Reinf., MF : 1.77 - Refer Table-3.10
Page 2 S2