Professional Documents
Culture Documents
Rameshwaram Institute of Technology & Management
Rameshwaram Institute of Technology & Management
Rameshwaram Institute of Technology & Management
10. Write any two differences between 1st angle and 3rd angle projection?
RCE 151
Attempt any four questions
(3)A point P is 60 mm from both the reference planes. Draw its projection in all possible position.
(4)Draw the projections of the following points i) in the HP and 20 mm behind VP ii) 40mm above the HP
and 30mm in front of VP iii)25mm below the HP and 35mm behind the VP.
(5)Draw the projection of a line PQ 10cm long in the following positions i) parallel to both the HP and VP
and 25mm from each ii) parallel to and 35mm above the HP and in the VP iii) parallel to and 40mm in front
of the VP and in the HP.
(6)A regular pentagon 0f 45mm side has one side on the ground. Its plane is inclined at 45 degree to the HP
and perpendicular to the VP. Draw its projection and show its traces.
RCE 151
Attempt any four questions
(3)A point P is 60 mm from both the reference planes. Draw its projection in all possible position.
(4)Draw the projections of the following points i) in the HP and 20 mm behind VP ii) 40mm above the HP
and 30mm in front of VP iii)25mm below the HP and 35mm behind the VP.
(5)Draw the projection of a line PQ 10cm long in the following positions i) parallel to both the HP and VP
and 25mm from each ii) parallel to and 35mm above the HP and in the VP iii) parallel to and 40mm in front
of the VP and in the HP.
(6)A regular pentagon 0f 45mm side has one side on the ground. Its plane is inclined at 45 degree to the HP
and perpendicular to the VP. Draw its projection and show its traces.
RAMESHWARAM INSTITUTE OF TECHNOLOGY & MANAGEMENT
5. The primary unit of measurement for engineering drawing and designin the mechanical
industries is……………………………..