Professional Documents
Culture Documents
Evaporation Pressure Parallel Control Experimental Equipment (E.P.R Control)
Evaporation Pressure Parallel Control Experimental Equipment (E.P.R Control)
NO. EQUIPMENT NAME MODEL (1) Being practicable to measure temperature at each of compressor inlet
PT. Graha Elektro Tama
Evaporation Pressure Parallel Control and outlet, condenser inlet and outlet, expansion V/V inlet and outlet,
KTE-2000EP evaporator outlet, inside chamber, and outside using thermo couples
Experimental Equipment (E.P.R Control)
of T-type.
(2) Measure of pressure: Being practicable to measure within the range of
I. IMAGE
-1bar ~ 35bar at each of compressor inlet and outlet, condenser outlet,
expansion V/V outlet, and evaporator inlet by pressure sensors which
are installed.
(3) Experiment factors: Being practicable to calculate each factor of like as
refrigeration effect, compressor work, condensing effect, evaporating
latent heat, amount of flash gas at expansion V/V outlet, dry rate and
humidity at expansion V/V outlet, and coefficient of performance in the
abstract with temperature and pressure data which are measure.
(4) Saving: Being saved on every minute until 1440min as excel file after
click the icon ‘SAVE’.
III. SPECIFICATION
1. Mechanical device
(1) Compressor: 3/4HP, for R-22, single 220V, Include Control Box
(2) Condenser and Fan motor: 3/4HP, Air cooling, single 220V, 60Hz, 16W
(3) Receiver: Cylinder type, Include a Service V/V
Appearance and specifications may be changed by the upgrade. 1) 1/2 Hp, 22kgf/cm2G, Pressure test(33kgf/cm2G)
2) Leak pressure(22kgf/cm2G), Down to 75℃, 90φ, 190mm, 265mm,
II. FEATURE 140mm
(4) Evaporator (High temperature): Cylinder type (Transparent acrylic),
1. Cycle composition: Compressor - Condenser - Receiver - Sight Glass – Filter Length 500mm, Diameter 300mm, Thickness 10mm,
Dryer - Solenoid Valve - Manual Expansion Value - Automatic Expansion Chamber door (1EA, Diameter 300mm, Thickness 10mm, Size (H8mm,
Valve - Low temperature Evaporator (installed a check valve at outlet) - L170mm, W170mm)
High Temperature Evaporator (installed an E.P.R at outlet) - Accumulator - (5) Evaporator (Low temperature): Cylinder type (Transparent acrylic),
KTE-2000EP
KTENG
Compressor. Length 500mm, Diameter 300mm, Thickness 10mm,
2. Being practicable to operate on manual, thermal control or pump down Chamber door (1EA, Diameter 300mm, Thickness 10mm, Size (H8mm,
with connecting by sequence or PLC control system (Include a textbook), L170mm, W170mm)
and function for Specification of Refrigerator Performance Automatic (6) Liquid Separator: 1HP, one inlet, VERTICAL TYPE
Measuring and Data Acquisition and System Monitoring Program. (7) Nipple: 1EA at each of high and low pressure
KTENG CORPORATION | 2013
6
AIR-CONDITIONING & REFRIGERATION EXPERIMENTAL EQIUPMENT
Jakarta, t: +62 21 385-6636 e: jakarta@grahaelektrotama.com | Surabaya, t: +62 31 534-8071 e: surabaya@grahaelektrotama.com
(8) Expansion V/V (Manual type) : Install at high or low evaporator (4) MC, RELAY MODULE
PT. Graha Elektro Tama
(9) Expansion V/V (Thermal sensing type): Install at high or low 1) Magnet Contact (DC24V), 13A, 5a, 2b
evaporator 2) Relay (DC24V, 8Pin)
(10) Solenoid V/V: ⅜″ Welding type 3) Relay base
(11) Filter dryer: ⅜″Welding type 4) Terminal
(12) Check V/V : ⅜″ Welding type 3. Performance Automatic Measuring Equipment
(13) E.P.R : 0 ~ 5.5bar, 1/2 ″ Welding type (1) Refrigerator Performance Automatic Measuring Equipment (KTE-
(14) Pressure gages: 1EA each of high and low pressure, oil type 100DA)
(15) Sight glass : Welding type (2) Data Acquisition and System Monitoring Program (KTE-100SMP)
2. Automatic control part 1) Function : Monitoring the measured data of temperature and
(1) POWER, LAMP, PRESSURE MODULE pressure in real time, and enthalpy on a diagram of the
1) S.M.P.S (24V 3.1A) refrigeration system in real time, and factors like as refrigeration
2) N.F.B (15A, Single) effect, compressor work, condensing heat in condenser,
3) Volt Meter (DC 30V Full scale) evaporating latent heat, amount of flash gas at expansion V/V
4) Am Meter (DC 3A Full scale) outlet, dry ratio at expansion V/V outlet, humidity at expansion
5) Buzzer (DC24V) V/V outlet, coefficient of performance in the abstract with
6) AC Lamp (220V) temperature and pressure data which are measure in real time,
7) Lamp (DC24V) and being saved data all of temperature, pressure and enthalpy on
8) Toggle S.W every minute as excel
9) Fuse & Holder 2) Composition: Main Page, Sector for display of temperature data,
10) D.P.S graph chart of temperature, display of pressure data, graph chart
11) Terminal of pressure, flowing diagram of the refrigeration system, display
(2) MC, RELAY TERMINAL MODULE the P-H chart of the refrigeration system on real time, setting
1) Magnet Contact (DC24V), 13A, 5a, 2b interval for saving data, and Run/Stop operation
2) Relay (DC24V, 8Pin)
3) Relay base IV. ACCESSORIES, GUARANTEE AND DELIVERY
4) Terminal
(3) S.W, TEMP MODULE
1. Power Cable: 1EA
1) Electronic Digital Temperature Meter (AC 220V, -40 ~ 100℃)
2. Connection Cable: 2EA
2) Electronic Digital Temperature controller (AC 220V, -40 ~ 100℃) 3. Banana jack: Red 20EA, Black 20EA
KTE-2000EP
KTENG
3) Push Button (1a) 4. Manual book 1EA
4) Push Button (1b) 5. Delivery: 3Month
5) Toggle Switch 6. Guarantee: For 1 year
6) Terminal
6
AIR-CONDITIONING & REFRIGERATION EXPERIMENTAL EQIUPMENT
Jakarta, t: +62 21 385-6636 e: jakarta@grahaelektrotama.com | Surabaya, t: +62 31 534-8071 e: surabaya@grahaelektrotama.com
PT. Graha Elektro Tama
NO. EQUIPMENT NAME MODEL 3. Should be available to study on software program about basic refrigeration
Refrigeration PLC Control Training Kit KTE-4000PL system, defrosting system, heat pump system, binary refrigeration system,
and brine refrigeration system.
I. IMAGE III. SPECIFICATION
KTE-2000EP
KTENG
air conditioning and refrigeration using in industrial field.
6
AIR-CONDITIONING & REFRIGERATION EXPERIMENTAL EQIUPMENT
Jakarta, t: +62 21 385-6636 e: jakarta@grahaelektrotama.com | Surabaya, t: +62 31 534-8071 e: surabaya@grahaelektrotama.com
3) Magnetic Switch (MC) with "a" "b" contact the circuit configuration
PT. Graha Elektro Tama
KTE-2000EP
KTENG
5) Experimental practice AUTO or MANUAL operation using a select
2) Lab experiments with the primary circuit to drive the switch
switch
configuration
6) 1 Experimental practice motor ON or OFF operation using a ‘A’
contact push button
6
AIR-CONDITIONING & REFRIGERATION EXPERIMENTAL EQIUPMENT
Jakarta, t: +62 21 385-6636 e: jakarta@grahaelektrotama.com | Surabaya, t: +62 31 534-8071 e: surabaya@grahaelektrotama.com
7) 2 Experimental practice motor ON or OFF operation using a ‘A’ 1) Configuration manual control circuit for "Evaporation pressure
PT. Graha Elektro Tama
KTE-2000EP
KTENG
3) Configuration temperature automatic control circuit of binary
4) Configuration compulsory pump down control circuit and operation refrigeration system and operation
(6) Evaporation pressure parallel control refrigeration system 4) Configuration pump down automatic control circuit at No.1 cycle,
and temperature automatic control operation and operation
6
AIR-CONDITIONING & REFRIGERATION EXPERIMENTAL EQIUPMENT
Jakarta, t: +62 21 385-6636 e: jakarta@grahaelektrotama.com | Surabaya, t: +62 31 534-8071 e: surabaya@grahaelektrotama.com
5) Configuration compulsory pump down operation and operation (18) Buzzer (DC24V)
PT. Graha Elektro Tama
1. Electric device
(1) N.F.B (30A, single)
(2) Magnet Contact (DC24V)
(3) Thermal Overload Relay
(4) Relay (DC24V, 8Pin)
(5) Relay Base (DC24V, 8Pin)
(6) Relay (DC24V, 11Pin)
(7) Relay Base (DC24V, 11Pin)
(8) IC Timer (DC24V, 60sec, 8Pin)
(9) IC Timer Base (DC24V, 8Pin)
(10) Flicker (DC24V, 60sec, 8Pin)
(11) Flicker Base (DC24V, 8Pin)
(12) Timer (DC24V, 24Hour)
(13) Terminal Base (20Pin)
KTE-2000EP
KTENG
(14) Terminal Base (15Pin)
(15) Terminal Base (10Pin)
(16) Terminal Base (3Pin)
(17) Lamp (DC24V)