The document discusses default bearer establishment and modification procedures in EPS networks. After a UE attaches to an EPS network, it enters a registered mode and a default bearer is set up along with selection of an S-GW and P-GW. The P-GW then assigns the UE an IP address when or after the default bearer is established. If the UE needs to transmit data to the same PDN and the default bearer meets quality of service requirements, it will use the default bearer for transmission to avoid activating additional PDP contexts.
Original Description:
Signalling Resource Block & Data Resource block in LTE
The document discusses default bearer establishment and modification procedures in EPS networks. After a UE attaches to an EPS network, it enters a registered mode and a default bearer is set up along with selection of an S-GW and P-GW. The P-GW then assigns the UE an IP address when or after the default bearer is established. If the UE needs to transmit data to the same PDN and the default bearer meets quality of service requirements, it will use the default bearer for transmission to avoid activating additional PDP contexts.
The document discusses default bearer establishment and modification procedures in EPS networks. After a UE attaches to an EPS network, it enters a registered mode and a default bearer is set up along with selection of an S-GW and P-GW. The P-GW then assigns the UE an IP address when or after the default bearer is established. If the UE needs to transmit data to the same PDN and the default bearer meets quality of service requirements, it will use the default bearer for transmission to avoid activating additional PDP contexts.
DRB modification procedure EPS Bearer introduction After the UE attaches to the EPS network, the UE enters EMM-REGISTERED mode, the default bearer has been set up, and the S-GW and P-GW have been selected for the UE. During network attach, the P- GW assigns an IP address to the UE when or after the default bearer is set up, as shown in the preceding figure, If the UE needs to transmit data to the same PDN and the default bearer meets the QoS requirements, the UE uses the default bearer for data transmission, avoiding PDP context activation.