Professional Documents
Culture Documents
Maccaferri - Macro 1: Secured Drapery System
Maccaferri - Macro 1: Secured Drapery System
Company Maccaferri
Designer -
Work Yard -
Date 10-Aug-18
Inclination of the most dangerous joint (put 45° if unknown) [°] 25.00
Compressive Strength of the most dangerous joint (JCS) JCS0 [MPa] 15.00
Effective rock compressive strength JCS = JCS0 (iy / 0.1) (-0.03*JRC0) [MPa] 5.10
SEISMIC ACCELERATION
Control: Safety factor to reduce stabilising forces RW = THl WG BH [-] 1.65
Control: Safety coefficient to increase the driving forces DW = max(MO or OL ) [-] 1.10
ANCHOR BARS
MESH FACING
Safety coefficient for the tensile strength of the mesh MH [-] 2.00
Tension on the average slip surface plan = W/ix/iy cos [MPa] 0.03
Initial dilatance of the most dangerous joint = JRC / 3 Log(JCS/plan) [°] 4.43
Sliding plane driving force FDslp = (W sen + c cos ) DW [kN] 128.68
Stabilizing forces (with nails) acting on the superficial
FSslp = ((W sen ) (1- c)) / RW + R [kN] 173.98
sliding plane
Bar verification FSslp - FDslp > = 0 [kN] 45.30
Notes
Anchor: Stab. forces / Driving forces FSslp - FDslp > = 0 [-] 1.35
Anchor pull-out force from load on the mesh PMesh = ((WDbar - WSbar) cos ( + o)) ix [kN] 26.60
Anchor pull-out force due to global instability PRock = (FSslp – R – FDslp) cos (+ o) [kN] 18.68
Minimum bar length in the stable rock mass Ls = P / (π fdrill τlim / γgt) [m] 0.70
Minimum length (bar) in the unstable rock mass Li = (s / cos o) [m] 1.20
Assumed length of plasticization in the unstable rock mass Lp = 0.3 m (= 1.0 ft) [m] 0.30
Maximum rock volume that can slide between anchors V [m3/m] 1.20
Maximum rock weight that can slide between anchors Mb = V [kN/m] 35.99
Sum of driving forces acting on the sliding plane Mbdrv = (Mb sen + c cos ) DW [kN/m] 25.70
Sum of stabilizing forces acting on the sliding plane Mbstb = (Mb sen (1- c)) RW [kN/m] 6.90
Punching forces acting on the mesh M = (Mbdrv – Mbstb) sin () ix [kN] 19.93
Mesh deformation angle from horizontal (average value) p = arctg (bulg / 1.5) [°] 27.01
Notes
Oversizing factor of the mesh (Force-strength ratio of the Tadm / T > = 0 [-] 2.48
mesh)
The Officine Maccaferri SpA assumes no responsabilities for the drawings and calculations it provides, as they must be
intended as general indications to suggest the proper use of its product.