Professional Documents
Culture Documents
NUMBER: 2 8-09 S.M. REF.: Listed in Table Engine: Epa07 Dd15 DATE: February 2009
NUMBER: 2 8-09 S.M. REF.: Listed in Table Engine: Epa07 Dd15 DATE: February 2009
NOTE:
This measurement must be done within 30 seconds of Key ON; after this time has elapsed the
voltage will drop to approximately 9 volts. This is a normal condition.
8. Measure the voltage between pin 2 of the grid heater harness connector and ground.
[a] If the voltage is greater than 11.5, replace the grid heater.
[b] If the voltage is less than 11.5, cycle the ignition and recheck voltage. If voltage is still
below 11.5, repair wire between pin 2 of the grid heater harness connector and pin 41
of the MCM.
ADDITIONAL SERVICE INFORMATION
Additional service information is available in Power Service Literature.
Detroit Diesel®, DDC®, Series 60® and the spinning arrows design are registered trademarks of Detroit Diesel Corporation.
© Copyright 2009 Detroit Diesel Corporation. All rights reserved. Printed in U.S.A.