1) Students are to simulate two circuits in Simpowersystems by the due date of Monday, October 26th, 2015 at 1pm and submit their results printed on paper.
2) The first simulation involves a circuit with a 5 ohm resistor, 30 ohm resistor, 25mH inductor, and 100uF capacitor powered by a 10Vrms, 50Hz AC source. Students must show the oscilloscope graph, explain what is measured, and describe the circuit.
3) The second simulation involves a power system single-line diagram where students must show the voltage over 3 cycles at buses 1 and 2 and the current at the transmission point and for loads A and B.
1) Students are to simulate two circuits in Simpowersystems by the due date of Monday, October 26th, 2015 at 1pm and submit their results printed on paper.
2) The first simulation involves a circuit with a 5 ohm resistor, 30 ohm resistor, 25mH inductor, and 100uF capacitor powered by a 10Vrms, 50Hz AC source. Students must show the oscilloscope graph, explain what is measured, and describe the circuit.
3) The second simulation involves a power system single-line diagram where students must show the voltage over 3 cycles at buses 1 and 2 and the current at the transmission point and for loads A and B.
1) Students are to simulate two circuits in Simpowersystems by the due date of Monday, October 26th, 2015 at 1pm and submit their results printed on paper.
2) The first simulation involves a circuit with a 5 ohm resistor, 30 ohm resistor, 25mH inductor, and 100uF capacitor powered by a 10Vrms, 50Hz AC source. Students must show the oscilloscope graph, explain what is measured, and describe the circuit.
3) The second simulation involves a power system single-line diagram where students must show the voltage over 3 cycles at buses 1 and 2 and the current at the transmission point and for loads A and B.
max. Monday, Oct26, 2015 on 1pm to Mr. Ali/Mr.Joko
Printed on paper: the simulation & result
Simulate these problems by Simpowersystems,
with a = 2 last digits of your Student ID number! 1. Create a model to this circuit & answer these questions! a. Show the sketch of the graph from the (?) scope! b. What quantity/parameter will be shown by the scope? 5 ohm c. Explain by your-own words about this BEBAN circuit (include about the quantities shown aX10 Vrms Vpeak 30 ohm by u1, i1, product, etc.) 50 Hz 25 mH 100 F
2. Simulate this power system single-line diagram, and show :
a. The sketch of voltage in bus 1 & 2 (just in 3 cycles of wave)! b. The sketch of current at the transmission sending-point & used by load A & B!
Note : The use of multimeter component can give us a more efficient place than current measurement dan voltage measurement.
(Doi 10.1201/9781315316246-2) Perelmuter, Viktor - Renewable Energy Systems (Simulation With Simulink® and SimPowerSystems™) - Chapter 1 SimPowerSystems™ Models