Professional Documents
Culture Documents
5G NR
5G NR
5G NR
Or ii) HW 2 (Under validation) : intel Core i9 7980EX (18 cores) shall support
future configurations incl. MIMO; ex. supplier LDLC Pro part list attached (~3700
�)
Allows parallel LDPC SW decoder on 9 or 12 cores, up to 3 (tested) or 5 (ongoing)
segments per slot or 140Mb/s or LDPC on FPGA (same as above);
ii) FPGA board (1 mandatory) : EVALUATION KIT ZYNQ-7000 ZC706 ex. supplier Digikey
ref: 122-1904-ND (2427�)
Currently Gen2 using 4 lanes. Evolutions planned to Gen3 8 lanes.
iv) RF board : Analog Device Transceiver type ADRV9371 ; ex. supplier : Digikey
ADRV9371-W/PCBZ-ND ('WIDE TUNING RANGE 300MHZ-6HGZ' version) 1169�
v) Misc HW list :
- LO : ADRV9371 required a 30.72MHz reference, 2 solutions listed below
-> CPRO33-30.720 from http://www.crystek.com ($ 50) : this module require a
3.3V power
-> AST3TQ-T-30.720MHZ-28 + AST3TQ-EVAL from digikey (14� + 49� ) : this
solution require soldering capabilities.
- LO : 3.3V power cable. Both previous solution require a 3.3V power using a SMA
connector. The 3.3V is provided by the ADRV9371 board using a 2 pins 2.56 header
connector.
-> the header shall be soldered on the ADRV9371 board
-> the cable can be easily build (example from digikey ACX1915-ND + PRT-
09918-ND )
UE �C OAI SW versions
- OS Kernel version
i7: Ubuntu 14.04 3.19.0-61-lowlatency
i9: Ubuntu 17.10 4.13.0-21-lowlatency
LDPC IP on FPGA
gNB �C HW
gNB - SW
branch is gNB_mwc18_integration.
supports PHY-test only , 20/40/80MHz, SCS 60kHz, LDPC, adapted LTE L1 (tested with
UE descscribed above)
the throughput (mcs) is limited by the performance of the PC. For the intel Core i7
6900K PC mentioned above, the MCS is limited to 15, but it might be different on
other PCs and also with the USRP.
Other notes/ restrictions:
- some parameters are hard coded: in lte-softmodem.c: rf-config-file (for
ADRV9371_ZC706 target), numerology, in eNB_scheduler_phytest.c: mcs
- command line parameters to be used: --phy-test -O
<path_to_config_files>/enb.band7.tm1.100PRB.usrpx310.conf -E (for 3/4 sampling in
case of USRP X300)