This document is a table of contents for a report on modifying an angle plate jig. It lists 10 sections that will be covered in the report, including an introduction, descriptions of the original and modified jig designs, design modifications made, fabrication difficulties, total costs, and a conclusion. It also lists 10 figures that will be included in the report, showing views of the original and modified jigs, CAD models, and specific design modification details.
This document is a table of contents for a report on modifying an angle plate jig. It lists 10 sections that will be covered in the report, including an introduction, descriptions of the original and modified jig designs, design modifications made, fabrication difficulties, total costs, and a conclusion. It also lists 10 figures that will be included in the report, showing views of the original and modified jigs, CAD models, and specific design modification details.
This document is a table of contents for a report on modifying an angle plate jig. It lists 10 sections that will be covered in the report, including an introduction, descriptions of the original and modified jig designs, design modifications made, fabrication difficulties, total costs, and a conclusion. It also lists 10 figures that will be included in the report, showing views of the original and modified jigs, CAD models, and specific design modification details.
This document is a table of contents for a report on modifying an angle plate jig. It lists 10 sections that will be covered in the report, including an introduction, descriptions of the original and modified jig designs, design modifications made, fabrication difficulties, total costs, and a conclusion. It also lists 10 figures that will be included in the report, showing views of the original and modified jigs, CAD models, and specific design modification details.
1 INTRODUCTION 1 2 ANGLE PLATE JIG 1 3 PHOTOS OF ORIGINAL JIG (BEFORE BLACKENING) 4 4 PHOTOS OF ORIGINAL JIG (AFTER BLACKENING) 4 5 DESIGN MODIFICATION 1 (ON JIG PLATE) 6 6 DESIGN MODIFICATION 2 (ON JIG FEET AND BASE PLATE) 8 7 DIFFICULTIES FACED IN FABRICATION 9 8 TOTAL COST AFTER FABRICATION 10 9 CONCLUSION 10 LIST OF FIGURES S.NO FIGURE NAME PAGE NO 1 Typical Angle plate jig 1 2 Modified angle plate jig 2 3 Angle plate jig before Blackening 3 4 Jig at Disassembled condition 4 5 Jig at assembled condition with workpiece 5 6 CAD Model of Angle plate jig 6 7 Design modification in the assembly of Allen screw in Jig plate 7 8 Design modification in the Jig feet and base plate 8 9 CAD model of locator shaft 9 10 Locator shaft and component 9