Professional Documents
Culture Documents
Laboratory Worksheet: Light Structurelaboratory
Laboratory Worksheet: Light Structurelaboratory
LABORATORY WORKSHEET
1.0 OBJECTIVE
1.1 To observe the effect of redundant member in structure and to understand the
method of the analysing type of this structure.
3.0 THEORY
Basically the flexibility method uses the idea that energy stored in the frame
would be the same for a given load whether the frame is from redundant or not.
In other word, the external energy = internal energy.
In practice, the loads in the frame are calculated in its “released” from ( that is,
without the redundant member) and then calculated with a unit load in place of in
the redundant member and remaining members.
The redundant member load in given by:
Member force = Pn + f
Where,
P = Redundant member load (N)
l = length of members( as ratio of the shortest)
n = load in each member due to unit load in place of redundant member(N)
F = Force in each member when the frame is “release” (N)
Figure 2 shows the force in the frame due to the load of 250N. You should be able
to calculate these values from Experiment titled: Force in a Statically
Determinate truss
Figure 3 shows the loads in the member due to the unit load being applied to the
frame.
The redundant member is effectively part of the structure as the idealized in figure
2
Figure 3: Forces in the Truss due to the load on the Redundant member
3.0 PROCEDURE
1.0 Wind the thumbwheel on the ‘redundant’ member up to the boss and hand tighten it. Do
not use any tools to tighten the thumbwheel.
2.0 Apply the pre-load of 100N downward, re- zero the load cell and carefully zero the
digital indicator.
3.0 Carefully apply a load 250N and check the frame is stable and secure.
4.0 Return the load zero( leaving the 100N Preload). Recheck and re-zero the digital
indicator. Never apply loads greater than those specified on the equipment.
5.0 Apply loads in the increment shown in table1, recording the strain readings and the
digital indicator readings.
6.0 Subtract the initial (zero) strain reading ( be careful with your signs)and complete table
2.
7.0 Calculate the equipment members’ force at 250N and enter them into table 3.
8.0 Plot a graph of Load vs Deflection from Table 1 on the same axis as Load vs Deflection
when the redundant ‘removed’.
9.0 The calculation for redundant truss is made much simpler and easier if the tabular
method is used is used to sum up all of the “Fnl” and “n2l”
Faculty : Faculty of Civil and Environmental
Page 4
Engineering
Department : Structure And Material Engineering Edition
Checking No
Title Force in a statically Indeterminate Effective Date
Amendment Date
cantilever Truss
10. Refer to table 4 and enter in the values and carefully calculated the other terms as
Required.
11. Enter your result in to Table 3.
4.0 RESULT
1
2
3
4
5
6
7
8
Member Length
F n Fnl n2l pn Pn + f
1
2
3
4
5
6
7
8
Total
P = Total Fnl
Total n2l
Using the Young’ s Modulus relationship, calculate the equivalent member force. Complete the
experimental force in table 3. (ignore member 6 at this stage)
1.0 From table 3, compare your answer to the experimental values, comment on the
accuracy of your result.
2.0 Compare all of the member forces and the deflection to those from statically
determinate frame. Comment on them of economy and safety of the structure.
3.0 What problems could you for seen you were to use a redundant frame in a ‘real life’
application (Hint: Look at the zero values for the strain reading once you have
included redundant member by winding up thumbnut)