The resolution of an ADC is defined by dividing VREF by the total number of
possible conversion values. 2. The AM band of the Electromagnetic spectrum is between 535 KHz and 1605 kHz and the carrier waves are separated by 10 kHz. 3. The FM band of the electromagnetic spectrum is between 88 MHz and 108 MHz and the carrier waves for individual stations are separated by 200 kHz for a maximum of 100 stations. 4. A transistor has current gain of 0.99 when used in common base (CB) configuration. How much will be the current gain of this transistor in common emitter (CE) configuration? (Ans. 99) https://stemez.com/subjects/joint_entrance_examination/1rjeephysics/1rjeephysics/1R JeePhysics/1R00-Ch19.htm 5. A transistor has a current gain of 0.99 in the CB mode. Its current gain in the CC mode is 100. A transistor has a current gain of 0.99 in the CB mode. Its current gain in the CE mode is 99. 6. In capacitively coupled amplifiers, the coupling and bypass capacitors affect the low frequency cutoff[They form H/P filters]. 7. A bypass capacitor causes reduced gain at low-frequencies and has a high-pass filter response. 8. The by-pass capacitor is instead in parallel with the RE and in series to with the 9. As the damping constant increases, the speed of response increases and the oscillations decay more rapidly. 10. For a second order system with no zeros, the percent overshoot to a unit step is a function of a. undamped natural frequency only b. damping ratio only [ANS] c. both 11. The output of a second order system is damped oscillatory. The poles of this system are a. negative real b. complex conjugate with negative real values b. complex conjugate with positive real values 12. The poles of a second order system have negative real values and are repeated. The nature of the response is a. Overdamped b. Underdamped c. Critically damped 13. The poles of a second order system have negative real values and are repeated. If the magnitude of one of the poles is increased, the nature of the response will become a. Overdamped b. Underdamped c. Critically damped 14. For a stable second order system, the damping factor is increased. This will result in a. increase in percent overshoot b. decrease in percent overshoot c. no change in percent overshoot 15. Diodes and MOSFET devices are non-linear devices and consequently produce several harmonic signals.
Today #22_04_2019, done with #NTC interview...
It hardly took 5 mins and they asked: About personal details including residence, education, work experience and father occupation .... Technical questions were like: Parts of a computer? Which programming languages do you know about? Whats VLAN and VPAN?? Whats STM?? Whats SONET and SDH and their difference?? Thats it....