ETERDCSNirma Uv 25.29 May 2009
Step 8: Performance based design using pushover analysis
Design is cari out as per IS 486-2000 than sect all beam to assign hinge properties from
[Assign > Frame/Line> Prame Nonlinear Hinges command
tint FE
in —
pe r
ETABS24ETERDCSNirma Uv 25.29 May 2009
Defining static nonlinear load cases from Define > Static Nonlinear Pushover command.
For push over analysis first apply the gravity loading as PUSHDOWN shown in Figure and
subsequently use lateral displacement or lateral force ax PUSH 2 in sequence to derive
‘nd demand curve as shown in Figure. tat from previous pushover ease as
for gravity loads i considered for lateral loading as PUSH 2.
ate None Eat Hane mm —
Lone nemunsoaasin
Peametetaene To Nomen
: cera
seus BEG) [FORTS] tommneawatee
Setntan | fs) towne
(tee || Fe
aS ase
a
tooo LR — [FORE] emoneatecve
So
oo |= 3
a Se
Sea oy
= oan
mal
Push? lateral Toad eases
ETABS25ETERDCSNirma Uv 25.29 May 2009
Run the Pushover analysis Hom Analysis > Run Static Nonlinear Analysis command
Posie
‘hod opts.
Review the pushover analysis resus from Display > Show Static Pushover Curve
‘command,
See wee ee Te ae eo! r
tae col ag -
ETABS26