Professional Documents
Culture Documents
Alert Service Bulletin 429-12-06: ASB 429-12-06B Page 1 of 4 Eccn Ear99
Alert Service Bulletin 429-12-06: ASB 429-12-06B Page 1 of 4 Eccn Ear99
Alert Service Bulletin 429-12-06: ASB 429-12-06B Page 1 of 4 Eccn Ear99
29 May 2012
Revision B, 30 August 2012
DESCRIPTION:
The length of the existing retaining lanyard of the transmission oil filler cap and adapter
assembly P/N 417-1474-1 is too long and may cause the cap to interfere with the flight
controls if the latter has not been reinstalled after servicing the transmission. This
bulletin introduces a new oil filler cap and adapter assembly P/N 417-1474-3 which
includes a shorter retaining lanyard P/N 417-1894. This bulletin also provides
instructions to replace the retaining lanyard of the existing cap and adapter assembly
P/N 417-1474-1 with a shorter retaining lanyard P/N 417-1894 making the cap and
adapter assembly equivalent to P/N 417-1474-3.
Revision A of this bulletin provides a new anchor point for the oil filler cap lanyard.
Revision B of this bulletin provides the correct part number for the bracket in the
materials section.
APPROVAL:
The engineering design aspects of this bulletin are Transport Canada Civil Aviation
(TCCA) approved.
ASB 429-12-06B
Page 1 of 4
ECCN EAR99
CONTACT INFO:
MANPOWER:
WARRANTY:
Owners / Operators of Bell Helicopters who comply with the instructions in this Bulletin
will be eligible to receive a credit for the replacement part.
Customers who fail to comply with the instructions in this Bulletin before the 31st
December 2012 are not eligible for the special warranty credit listed above. There is no
labor associated with this bulletin.
MATERIAL:
Required Material:
The following material is required for the accomplishment of this bulletin and may be
obtained through your Bell Helicopter Textron Supply Center.
Note 1: Operators who have complied with the initial release of this bulletin do not need
to order a new lanyard.
Consumable Material:
None required.
ASB 429-12-06B
Page 2 of 4
ECCN EAR99
SPECIAL TOOLS:
None required.
Not affected.
Not affected.
REFERENCES:
PUBLICATIONS AFFECTED:
ACCOMPLISHMENT INSTRUCTIONS:
1. Gain access to oil filler cap (1, Figure 1) through transmission cowl door assembly
(600FL).
4. If not already accomplished, remove the existing lanyard and install the new
shorter lanyard P/N 417-1894. Attach one end of the lanyard to the cap (1) and the
other to the bracket (3).
5. Using indelible ink, re-identify oil filler cap and adapter assembly by adding P/N
417-1474-3 on the adapter (5) unless already carried out per the initial release of
this bulletin.
ASB 429-12-06B
Page 3 of 4
ECCN EAR99
Figure 1. Transmission oil filler cap lanyard - installation
ASB 429-12-06B
Page 4 of 4
ECCN EAR99