Professional Documents
Culture Documents
Pulsonic 5.2: Pressure Oiler: Optimum Lubrication For Needles and Lifters
Pulsonic 5.2: Pressure Oiler: Optimum Lubrication For Needles and Lifters
Pulsonic 5.2: Pressure Oiler: Optimum Lubrication For Needles and Lifters
2
Pressure oiler: Optimum lubrication for
needles and lifters
Advantages
The PULSONIC 5.2 lubrication system precisely meters a small ■■ Uniform distribution of oil over the entire cylinder - no oily
amount of oil per pulse to ensure that oil is only distributed to stripes caused by excessive lubrication
the points required. It is possible to individually program the ■■ Fewer oil spots on fabric
amount of oil fed to each lubrication point. The system greatly ■■ Individual lubrication programmes for needles and sinkers
reduces oil consumption. The external surface of the knitting ■■ Lower oil consumption thanks to precision metering
machine remain dryer and the number of oil spots on the knitted ■■ No unhealthy, harmful oil mist
fabric is greatly reduced. ■■ Lower power costs due to savings in compressed air
■■ Dry surfaces ensure less lint build-up
The PULSONIC 5.2 is available with 12 or 24 oil outlets. The unit
■■ Electronic monitoring of oil supply to lubrication points.
is set using the buttons alongside the easy-to-read display.
If no oil is present, the knitting machine is shut down
■■ Yearly oil consumption can be calculated accurately
Reciprocating rotary piston Fuko sensor NKS needle head lubrica- Flush/Wash (optional)
A stepping motor controls the re- A series of sensors monitor the tion (optional) The Flush/Wash function flushes
ciprocating, rotary motion of the operation and oil flow of the The optional NKS needle head the knitting elements with oil.
piston. When the motor starts, PULSONIC 5.2. System faults lubrication is used to lubricate Any dirt present is flushed out
the piston is pushed downwards are shown on the display. the knitting machine compo- and washed away ensuring that
and the required amount of oil nents subject to high stresses. is does not get on to the knitted
is pumped out at the selected Optimum lubrication intervals is fabric during production. This
lubrication point. When the pis- programmed by the user function can only be used with a
ton is raised it creates a vacuum intervals. The needle heads and machine controller.
and draws in new oil from the oil latches are lubricated with an
reservoir through an inlet valve. air-oil mixture. This lengthens the
service life of needles.
Technical Data
Power supply: 24V (20-33 V) 50/60 Hz Oil reservoir capacity: 3.5 litre
Run signal (machine is running): 10 – 30 V AC Weight: 3 kg (approx.)
Max. power: 72 VA With optional NKS needle head lubrication the following are also
Displacement per pump stroke: 4.2 – 25 mm³ required:
Adjustable oil dose per lubrication point: 0.3 – 24 ml/h Compressed air supply: 3 bar (max.)
(dry - no condensate)
Max. oil consumption (with all nozzles operating):
Compressed air consumption at 1.5 bar: 0.5 N m³/h
Pulsonic 5.2: 288 ml/h
for 3 NKS nozzles
Pulsonic 5.2/24: 288 ml/h
050.905.960.01/0915