Professional Documents
Culture Documents
LP 2 Lez Elem OLI
LP 2 Lez Elem OLI
LP 2 Lez Elem OLI
GB AWG 853 B A
A. “On/Off” indicator light
B. “On/Off” button
kg rpm °C
Cotton with Heavily soiled, long wearing and temperature stable textiles in cotton and linen
1 prewash (bed linen, table linen, underwear, shirts etc.). 3.5 yes yes ❉ 1 ❉ — ❉ — Max. 90°
Normally soiled bed linen, table linen and underwear, towels, shirts etc. made of cotton
2 Cotton and linen. 3.5 — yes ❉ 1 ❉ — ❉ — Max. 90°
Average to heavily soiled, long wearing and temperature stable textiles in cotton and
3 Coloured Cotton linen. 3.5 — yes ❉ 1 — — ❉ — Max. 60°
Slightly soiled bed linen, table linen and underwear, towels, shirts etc. made of cotton and
4 Quick wash linen. 3.5 — yes ❉ 1 — — ❉ — Max. 40°
Special rinse for Programme for treating wash with starch or softener.
B cotton wash — The programme ends with a long spin cycle. 3.5 — — ❉ 1 — — — — —
C Drain + Spin — Drain, with final spin. Alternative method for unloading laundry earlier. 3.5 — — — 1 — — — — —
Synthetic with Heavily soiled shirts, blouses, overalls etc. made of polyester (Diolen, Trevira), polyamide
5 prewash (Perlon, Nylon) or blends with cotton. 2.0 yes yes ❉ 2 — ❉ ❉ — Max. 60°
Slightly to normally soiled blouses, shirts, overalls etc. made of polyester (Diolen, Trevira),
6 Synthetic polyamide (Perlon, Nylon) or blends with cotton. 2.0 — yes ❉ 2 — ❉ ❉ — Max. 60°
Special rinse for Programme for treating wash with starch or softener.
B synthetic fabrics — The programme ends with a long spin cycle. 2.0 — — ❉ 2 — ❉ — — —
Drain, with final spin. Alternative method for terminating the “Synthetic”, “Delicate” and
D Drain + Spin — “Wool” programme and unload the laundry earlier. 2.0 — — — 2 — — — — —
Drain + Spin Drain, with final spin. Alternative method for terminating the “Synthetic”, “Delicate” and
D for wool — “Wool” programme and unload the laundry earlier. 1.0 — — — 2 — — — — —
CONSUMPTION DATA “Half Load” button (depending on model) TO INTERRUPT THE RUNNING PROGRAMME
• Reduces water consumption above all during
rinsing. To interrupt the running programme and continue
Temperature Load Water Energy Approx. • Suitable for lightly soiled laundry and small it at a later time:
Selector Programme loads (max 2.5 kg). 1. Press the “ON/OFF” button.
Programme
Duration Note: reduce the detergent quantity. 2. After the desired interval has passed, press the
(°C) (kg) (l) (kWh) (hours:minutes)
“ON/OFF” button again.
2 - Cotton 90° 3.5 46 1.28 2:05 DOOR LOCK
3 - Cotton 60° 3.5 42 0.65 1:50 END OF WASH CYCLE
The door locks automatically after the programme
3 - Cotton 40° 3.5 47.2 1.00 1:02 start until the end of the programme. If the 1. At the end of the programme the programme
6 - Synthetics 60° 2.0 46 0.68 1:12 programme selector is moved to the “Stop” selector moves to the “Stop” position.
position or if the electricity supply is interrupted, 2. To unload the machine wait for the door to
6 - Synthetics 40° 2.0 46 0.34 1:03 then after approximately two minutes the door is
unlock (approx. 2 minutes).
7 - Wool 40° 1.0 45 0.25 0:46 released. In this case do not open the door,
3. Switch off the appliance, open the door and
Prewash cycle increases programme duration by approx. 15 minutes. Consumption data were measured in normalized because hot water could come out of the door.
unload the washing.
conditions in compliance with Standard IEC 60 456. The data on the “Energy Label” refer to programme “Coloured Cotton
PROGRAMME RESELECTION 4. Close the tap and leave the door ajar to allow
60° C”. Consumption data in the home may vary with respect to the values in the table in relation to the water supply
pressure and temperature, the load and the type of wash. To change a programme when a cycle has already the drum to dry out.
“Eco Wash” button begun:
ADD DETERGENT, CLOSE THE DOOR
(eco) NOTES AND INDICATIONS FOR USE
AND SELECT THE PROGRAMME (depending on model) 1. Switch off the appliance by pressing the
“ON/OFF” button. • SPIN SPEED CONTROL
• Reduces the temperature to 60° when the
Add the detergent as described in the programme 2. Select the new programme. Spin speed may be reduced automatically or
thermostat is set to a higher temperature.
table or in the chapter “Detergent and Additives” in may even be excluded in case of small loads
“Rinse Hold” button (depending on model) 3. Start the programme by pressing the
the booklet. containing highly absorbing garments (e.g.
in synthetic and wool programmes only “ON/OFF” button.
1. Make sure that the Programme selector is set to bath robes, towels, etc).
• The laundry remains in the last rinse water This reduces damage to fabric and to the
“Stop”.
without progressing to the final spin cycle to machine and prevents excessive vibration and
2. Open the tap. avoid creasing and prevent colours from
3. Set the programme selector to the desired noise in the machine due to an unbalanced
changing. load: by selecting high spin speeds the noise
programme. • This option is particularly recommended for the level increases.
4. Set the thermostat knob to the desired programme “Synthetics” or “Delicate”. • CLEANING THE FILTER
temperature. • This function is particularly useful if you want to To ensure an impeccable function of the pump,
5. Set the spin selector knob to the desired speed. postpone spinning to a later time or when you do check the filter regular and clean it if
6. Special options can be selected, if required. not wish to spin the clothes. necessary.
7. Check that the door is well closed and turn on the To terminate the “Rinse Hold” • THERMOSTAT KNOB
washing machine by pressing the “ON/OFF” option (depending on model) This is set by turning the knob until it reaches
button. The indicator lights up, indicating that in synthetic and wool programmes only the desired temperature.
the washing machine is on. • Press the Rinse hold button again; the load will
SELECT ANY DESIRED OPTION be spun according to the selected programme.
If you do not wish to spin the clothes, turn the
“Spin speed reduction” button programme selector knob to the drain programme,
• Reduces the predetermined automatic maximum after pressing the “No Spin“ button.
spin speed.
In some programmes the maximum final spin
speed is limited to go easy on your laundry items.
Selection of a higher spin speed is not possible.