Download as docx, pdf, or txt
Download as docx, pdf, or txt
You are on page 1of 13

THESIS TITLE

by

Student Name (Student ID)


Student Name (Student ID)
Student Name (Student ID)

A Thesis Submitted to the Academic Faculty in Partial Fulfillment of the


Requirements for the Degree of

BACHELOR OF SCIENCE IN ELECTRICAL AND ELECTRONIC


ENGINEERING

Department of Electrical and Electronic Engineering


Islamic University of Technology (IUT)
Gazipur, Bangladesh

November 2018
i
THESIS TITLE

Approved by:

--------------------------------------------

Dr. XXX

Supervisor and [Associate/Assistant] Professor,


Department of Electrical and Electronic Engineering,
Islamic University of Technology (IUT),
Boardbazar, Gazipur-1704.

Date: ……

i
Table of Contents

List of Tables ..................................................................................................... iii


List of Figures .....................................................................................................iv
List of Acronyms ................................................................................................. v
Acknowledgements.............................................................................................vi
Abstract ..............................................................................................................vii
1 Introduction .................................................................................................... 1
1.1 BASIC FUNCTIONALITIES OF ........................................................................................ 1
1.2 DIFFERENT ASPECTS ................................................................................................... 1
1.3 BACKGROUND AND MOTIVATION ................................................................................ 1
2 Overview of .................................................................................................... 2
2.1 INTRODUCTION ............................................................................................................ 2
2.2 NETWORK ARCHITECTURE........................................................................................... 2

ii
List of Tables

Table 2.1 Evolution of 3GPP technologies ............................................................................... 2

iii
List of Figures

Figure 2.1: Network architecture for EPS ................................................................................ 2

iv
List of Acronyms

AM Acknowledged Mode
APN Access Point Name Packet Data Network

v
Acknowledgements

I would like to thank

YYYY

vi
Abstract

The …..

vii
Chapter 1

1Introduction
The ……
The major …….

1.1 Basic Functionalities of


The operation…..

1.2 Different Aspects …..


The research delves into ..

1.3 Background and Motivation


The research presented in this dissertation aims at…

1
Chapter 2

2Overview of ….
In order to meet the continued…

2.1 Introduction

The industry witnessed …

Table 2.1 Evolution of 3GPP technologies


Theoretical Multiplexing
Generation Technologies Service
Data Rate Technique

2G GSM Voice 9.6-19.2 kbps

GPRS Data 44-171.2 kbps FDMA/TDMA


2.5G

2.75G EDGE Data 384 kbps

2.2 Network Architecture


The evolved

Figure 2.1: Network architecture

2
2.2.1 The ….
The ….

2.2.2 The ….
The ……

3
Chapter 6

3Conclusion
Various aspects of

4
4References
[1] B. Zhou, H. Hu, S. Huang, and H. Chen, “Intra-cluster device-to-device relay algorithm
with optimal resource utilization,” IEEE Transactions on Vehicular Technology, vol. 62,
no. 5, pp. 2315–2326, Jun. 2013.
[2] Available: http://www.3glteinfo.com/lte-rlc-arq-procedure/ [Accessed 2018]

You might also like