Professional Documents
Culture Documents
Valves and Unit Injectors, Adjustment - Fuel Injection - Nut (Hardware)
Valves and Unit Injectors, Adjustment - Fuel Injection - Nut (Hardware)
Saved Info Embed Print
Cam Injector Intake Exhaust Exhaust
Position Non VCB
VCB
5 X X X
V6 X
3 X X X
V2 X
6 X X X
V4 X
2 X X X
V1 X
4 X X X
V5 X
1 X X X
V3 X
D
Volvo Trucks North America Date Group No. Page
Service Bulletin 7.2007 214 52 8(17)
19
Does not apply to valve bridge without locating
pin (non-adjustable):
38 ± 4 Nm (28 ± 3 ft-lb)
20
With the engine
approximately 60cold (engine
C (140 F),temperature of
continue adjustment on the
same inlet rocker by checking the valve clearance. Push
down on the back of the rocker and insert a feeler gauge
of the proper specification of 0.3 ± 0.05 mm (0.012 ±
0.002 in.) between the bridge and the adjustment screw.
If the inlet rocker requires adjustment, loosen the lock nut
on the rocker and adjust the plunger. Tighten the lock on
the plunger by holding the adjusting screw in place and
torque-tighten the lock nut to 38 ± 4 Nm (28 ± 3 ft-lb).
38 ± 4 Nm (28 ± 3 ft-lb)
W2005145
21
Recheck the valve clearance after the nut is tightened.
Note: Mark the rocker arm when the valve has been
adjusted.
D
22
To adjust the injector on the same cylinder location,
loosen the lock nut and back off the adjusting screw until
it no longer makes contact.
W2005148
23
Adjust the unit injector’s rocker arm to zero clearance.
24
Tighten the adjusting screw 4 flats or 240 degrees of
clockwise rotation.
25
Torque-tighten the adjusting screw lock nut to 52 ± 4
This document is...
Nm (38 ± 3 ft-lb).
52 ± 4 Nm (38 ± 3 ft-lb)
38 ± 4 Nm (28 ± 3 ft-lb)
27
Search
Recheck valve clearance after the nut is tightened.
Note: Mark the rocker arm when the valve has been
adjusted.