Professional Documents
Culture Documents
Pump Drive - Adjust: Testing and Adjusting
Pump Drive - Adjust: Testing and Adjusting
Pump Drive - Adjust: Testing and Adjusting
Welcome: crcestacionx3
Product: TRUCK
Model: 793D TRUCK FDB
Configuration: 793D Off-Highway Truck FDB00001-UP (MACHINE) POWERED
BY 3516B Engine
i01706653
Assembly Procedure
Refer to Disassembly and Assembly, "Pump Drive - Assemble" for final adjusting of the pump
drive.
Cleaning Procedure
1. Before assembly, ensure that all parts are clean. Also, ensure that all passages are free from
debris.
2. After the pump drive is fully assembled, connect the appropriate hardware in order to power
the yoke.
3. Use SAE 10W oil at 66 °C (150 °F). The oil must meet a minimum cleanliness of the
standard ISO 16/13. Supply the oil at 12 L/min (3.2 US gpm). Rotate the yoke at 2067 RPM
for 20 minutes.
4. Check for leaks, abnormal noise, or large debris in the drain port. Take corrective action if
any of these problems exist.
5. After this flushing procedure, the oil that is exiting the pump drive must meet a minimum
cleanliness of the standard ISO 16/13. If the drain oil does not meet this requirement, repeat
Steps 1 through 5 until the oil meets this requirement.
Copyright 1993 - 2016 Caterpillar Inc. Sat Feb 27 2016 10:25:47 GMT-0500
All Rights Reserved.
crcestacionx3
Private Network For SIS Licensees.
1 de 1 27/02/2016 10:25 a. m.