Professional Documents
Culture Documents
Important: Read and Save These Instructions. Air: Conditioner
Important: Read and Save These Instructions. Air: Conditioner
IMPORTANT:
Read and save
these instructions.
(IMPORTANT:
Air Conditioner
jInstaller: Leave Installation Instructions
with the homeowner.
Homeowner: Keep Installation Instructions
for future reference.
1 s ave Installation Instructions for local
electrical inspector’s use.
Order Through-the-Wall
7/oly\
Mounting Kit, Port No.
1158268 from authorized
parts distributor.
opening size
Electrical outlet must
be available within 7
the reach of the
Do Not use an
extension cord.
Electrical
requirements
Check location where air An electrical outlet must be
conditioner will be installed for available within reach of the
opening size, electrical outlet, and service cord. DO NOT USE AN
airflow. EXTENSION CORD. Electrical Shock Hazard
The opening dimensions must l Electrical ground is required
have a 24-7/8” width and 15-l j4” on this appliance.
height. l Do Not modify the power
supply cord plug. If it does not
fit the outlet, have a proper
outlet installed by a qualified
Electrical Shock Hazard electrician.
. Do Not have a fuse in the
It is the customer’s responsibility: Electrical Code, ANSI/NFPA 70- neutral or grounding circuit.
* TO contact a qualified electri- latest edition, and all local A fuse in the neutral or
cc11installer. codes and ordinances. grounding circuit could result
l To assure that the electrical Failure to do so could result in in electric shock.
installation is adequate and in fire, electrical shock or other Do Not use an extension cord
l
requirements construction
Page 3
1 n
Remove the rear grille from
the air conditioner
discard the grille. ~;--~
and
Personal Injury/Product
Damage Hazard Secure air conditioner in
2 n
Install the sleeve by
following the installation
instructions that came with it.
l Maintain a firm hold on the air 8 n opening. Go to Step 9.
conditioner to prevent it from tab
falling out of the opening
-during installation.
Failure to follow this instruction
tront panel
3 n
Follow THROUGH-THE-WALL
INSTALLATION, Steps 9
through 11 to complete installa-
could result in personal injury or tion.
damage to the air conditioner. screw
lik
air conditioner
9 Remove sheet metal
n screws from front base
flange. Insert tabs on the top
If your air conditioner
not operating properly...
is
Check that the circuit breaker is
edge of front panel into slots in the not tripped or house fuse blown.
air conditioner cabinet. Use two Check that power supply cord is
screws to attach the bottom of securely plugged into the
the front panel to the cabinet. electrical outlet.
Wall/Floor Damage
11 If needed, install
moldina around
n
room side of cabinet.
Whirlpool Consumer Assistance
Center is open 24 hours u day, 7
days a week. Just dial (800) 253-l 301
Check that air conditioner is -the call is free. When you call, you
tilted to the outside so that will need the air conditioner model
water will run to the outside. number and serial number. Both
Failure to do so may cause numbers are found on model and
damage to wall/floor coverings. serial label located behind the front
panel on the base flange.