CNC SYSTEMS
OSP5020M
OSPSOOM-G
Enhanced Function Manual
(1st Edition)
ME32-021-R13643-E P-()
SAFETY PRECAUTIONS
SAFETY PRECAUTIONS
‘The machine is equipped with a variety of safety devices designed to protect prevent accidents and
Injuries from occurring. Still, operators must use the machine carefully and learn not to rely on these
safety devices.
This section describes the general safety precautions required for machine operation. Every operator
must read this section carefully and observe the guidelines it describes.
Before Turning on the Power
(1) Make sure that doors to the operation panel and the electric control cabinet are closed.
(2) Do not put any obstacles on or around the machine.
(3) Turn on the main power switch before turing on the CONTROL ON switch on the operation
panel.
(4) Make sure that there is not dangerous elements around the machine.
In Manual or Continuous Operation
(1) Always follow the operation manual.
(2) Never operate the machine without closing the front shied.
(8) In initial grinding, check for operating conditions and interference according to the steps from no-
load run to single block grinding to continuous operation.
(4) Ensure the safety before rotating or moving the spindle,
(5) Check the tool offset values.
(6) Check the zero offset values.
(7) Ensure that the spindle speed and feedrate override switches are set at 100 %. Operate the
machine carefully and stop it immediately in case of abnormality. If necessary, sot the feedrate
override switch to 5, 10, and 60 % etc.
(8) Never attempt to touch the spindle or tool in rotation.
(9) Do not touch the spindle or the tool when indexing or changing speed. The spindle may turn,
(10) Never apply @ rotating torque to the spindle by operations such as retightening of milling chuck
before the spindle is completely indexed. The spindle may turn.
(11) Do not turn the spindle with the tool or othor parts loosely fixed
(12) Be sure to stop the spindle tool and use a brush or broom when removing chips adhering to the
spindle.
(13) Cutting operation causes scatter of chips, coolant, and in some cases fragments of the tool.
Be sure to close the cover and stay away from the spindle.
(14) Load a workpiece securely on the table. After loading, ensure that there are no tightening tools
left on the table,