Professional Documents
Culture Documents
University of Pune, Online Examination System, Question Bank Course
University of Pune, Online Examination System, Question Bank Course
Course
Id
Question The diagram, which depicts a horizontal piping system,
viewed from directly overhead, that delivers a constant flow
of water through pipes of varying relative diameterslabeled 1
through 5.
At which of the labeled points is the water in the pipe under
the lowest pressure?
A 1
B 2
C 3
D 4
Answer B
Marks 1
Unit IV-C4
Id
Question A fountain emitting a single stream of water (density 1000
kg/m3) at a playground is fed from a vertical pipe that is
below ground but whose opening is at ground level as shown.
At the ground-level opening, the pipe's diameter is 0.06 m
and the water exits the pipewith a velocity of 9.0 m/s upward.
The volume flow rate of the water as it exits the pipe.
A 10-2 m3/s
B 2.5 ×10-2 m3/s
C 1.5×10-2 m3/s
D 1.11 ×10-2 m3/s
Answer B
Marks 1
Unit IV-C4
Id
Question A fountain emitting a single stream of water (density 1000
kg/m3) at a playground is fed from a vertical pipe that is
below ground but whose opening is at ground level as
shown. At the ground-level opening, the pipe's diameter is
0.06 m and the water exits the pipewith a velocity of 9.0 m/s
upward
The fountain's lower end of the underground pipe has a
diameter of 0.12 m and is 6.0 m below the ground. The
absolute pressure in the underground pipe at a depth of 6.0
m is
A 1.73
B 2.7
C 7.1
D 3.0
Answer A
Marks 1
Unit IV-C4
Id
Question A person suffering from shortness of breath visits a doctor,
who discovers that blood flow in an artery (shown here) is
severely restricted, noting that the flow at position 2 in the
artery is three times faster than at position 1. (For the
purposes of this problem, assume human blood is an ideal
fluid.
If the average density of human blood is 1060 kg/m 3 and the
blood's speed at position 1 is 0.1 m/s, then the pressure
gradient ΔP between positions 1 and 2 (assume the heights of
1and 2 are equal).
A 42 Pa.
B 72 Pa.
C 12 Pa.
D 32 Pa.
Answer A
Marks 1
Unit IV-C4
Id
Question A 4 cm diameter orifice in the vertical side of the tank
discharges water. The water surface in the tank is at a
constant level of 2.0 m above the centre of orifice. If head
loss in the orifice is 0.20 m and the co-efficient of contraction
is 0.63, determine the value of coefficient of discharge.
A 0.98
B 0.65
C 0.59
D 0.75
Answer C
Marks 1
Unit IV-C4
Id
Question A 4 cm diameter orifice in the vertical side of the tank
discharges water. The water surface in the tank is at a
constant level of 2.0 m above the centre of orifice. If head
loss in the orifice is 0.20 m and the co-efficient of contraction
is 0.63, determine the discharge through the orifice, if Cv =
0.95.
A 0.001 m3/s
B 0.0047 m3/s
C 2.5 m3/s
D 0.03 m3/s
Answer B
Marks 1
Unit IV-C4
Id
Question A 4 cm diameter orifice in the vertical side of the tank
discharges water. The water surface in the tank is at a
constant level of 2.0 m above the centre of orifice. If head
loss in the orifice is 0.20 m and the co-efficient of contraction
is 0.63, determine the value of coefficient of discharge.
A 0.98
B 0.65
C 0.59
D 0.75
Answer C
Marks 1
Unit IV-C4
Id
Question At a section A in the horizontal pipe, the diameter 6 cm,
pressure 80 kN/m2 and velocity is 32 m/s. The total energy of
A is ……..
A 18.9 m
B 50.6 m
C 56.2 m
D 60.4 m
Answer D
Marks 1
Unit IV-C4
Id
Question If the velocity of flow is 4 m/s, then the velocity head should
be…..
A 0.46 m
B 1m
C 1.50 m
D 0.815 m
Answer D
Marks 1
Unit IV-C4
Id
Question A 10 cm diameter pipe has a nozzle at its end. If the velocity
in the pipe is 2.5 m/s and the pressure is 50 kpa, determine the
velocity of jet. Consider Cv = 0.98
A 0.911 m/s
B 10.11 m/s
C 15.23 m/s
D 0.112 m/s
Answer B
Marks 1
Unit IV-C4
Id
Question
A Always from A to B
B From A to B if HA+HL= HB
C From B to A if HA +HL= HB
D From B to A if HB +HL= HA
Answer C
Marks 1
Unit IV-C4
Id
Question
Marks 1
Unit IV-C
Id
Question A long pipe as shown if fitted with venturimeter 'V '& orifice-
A 450.85 kN/m2
B 436.8 kN/m2
C 322.8 kN/m2
D 155.6 kN/m2
Answer B
Marks 1
Unit IV-C4
Id
Question A uniform diameter pipe of 25 cm is placed inclined as
shown. During the flow of a fluid, the energy loss at section
1-1 is 15.187m and that at 2-2 is 14.122m was observed.
A 0.18 2m3/s
B 0.351m3/s
C 0.148m3/s
D 1.5m3/s
Answer C
Marks 1
Unit IV-C4
Id
Question A 4 cm diameter orifice in the vertical side of the tank
discharges water. The water surface in the tank is at a
constant level of 2.0 m above the centre of orifice. If head
loss in the orifice is 0.20 m and the co-efficient of
contraction is 0.63, determine the discharge through the
orifice, if Cv = 0.95.
A 0.001 m3/s
B 0.0047 m3/s
C 2.5 m3/s
D 0.03m3/s
Answer B
Marks 1
Unit IV-C4