Professional Documents
Culture Documents
Projects Group Basic Data For Flowsheet Draughting Foster Wheeler Engineering Standard
Projects Group Basic Data For Flowsheet Draughting Foster Wheeler Engineering Standard
01A2 (Reading)
BASIC DATA FOR FOSTER WHEELER PAGE: 1 OF 8
FLOWSHEET ENGINEERING STANDARD REV: 1
DRAUGHTING
Contract:
Client's Name:
Project Title:
Project Location:
CONTENTS
SECTION SUBJECT
1. PREPARATION
2. SYMBOLOGY
3. TITLE BLOCKS
5. EQUIPMENT DATA
6. DRAWING SIZES
7. TEXT SIZES
8. DRAWING NUMBERING
9. REVISING DRAWINGS
11. DISTRIBUTION
1.0 PREPARATION
1.1 Basic Data for Flowsheet Draughting shall be prepared by the Project
Co-ordinating Engineer, or Process Co-ordinating Engineer if there is no
Project Engineer, at the start of the project.
1.2 This Engineering Standard does not replace ENG.STD. 50F2 (Reading)
which shall be used at all times for job specification development unless
client's standards overrule.
1.3 All sections of this Engineering Standard shall be filled in. If a section is
not applicable, enter N.A. in the appropriate remarks section. If data is
applicable but not available at the time of issue, enter LATER in the
appropriate section.
2.0 SYMBOLOGY
Remarks
Remarks
2.3 If client's own symbols are to be used full details shall be provided.
Remarks
Remarks
Remarks
Remarks
Remarks
Remarks
Remarks
Remarks
Remarks
5. EQUIPMENT DATA
Remarks
Remarks
Remarks
Remarks
Remarks
9. REVISING DRAWINGS
Remarks
c) Arrows YES NO
Remarks
10.2 If client's standards are to be used the total number of digits per line
shall as a minimum be provided
Remarks
Remarks
Remark
10.5 If "NO" to 10.4, full details of the required format shall be provided
Remarks
11.0 DISTRIBUTION
Remarks