SABIT MC - 1 is a cold-applied, easy to use cut-back asphalt product that meets MOC specifications for road and bridge construction. It does not require thinning or heating and is suitable for use as a prime coat when sprayed onto asphalt or granular surfaces at a rate of 0.65 - 1.75 liters per square meter. Workers should take safety precautions when using this product due to its volatile solvents.
SABIT MC - 1 is a cold-applied, easy to use cut-back asphalt product that meets MOC specifications for road and bridge construction. It does not require thinning or heating and is suitable for use as a prime coat when sprayed onto asphalt or granular surfaces at a rate of 0.65 - 1.75 liters per square meter. Workers should take safety precautions when using this product due to its volatile solvents.
SABIT MC - 1 is a cold-applied, easy to use cut-back asphalt product that meets MOC specifications for road and bridge construction. It does not require thinning or heating and is suitable for use as a prime coat when sprayed onto asphalt or granular surfaces at a rate of 0.65 - 1.75 liters per square meter. Workers should take safety precautions when using this product due to its volatile solvents.
Specification for Road and Bridge Construction Table 3 of section 4.04) Introduction: Health & Safety: SABIT MC - 1, Cold applied product, easy to Workers should wear protective gloves, and apply, it doesn't need thinning or heating. goggles during application. SABIT MC - 1 contains volatile solvent and have low flash Uses & Application: point. Care must be taken to ensure that there is SABIT MC - 1 suitable for use in the construc- adequate ventilation in the working place. Fires tion & maintenance of pavement as designated and naked flames should be kept at a distance. in MOC Specification. It is ideal for prime coat. Packing & Storage: SABIT MC - 1 is applied to asphalt or granular surfaces using truck mounted spray equipment. SABIT MC - 1 can be supplied In bulk, drums and cans. Store in dry and shaded area in Coverage: original packing. The container should be kept Priming is accomplished by spraying 0.65 - 1.75 covered while working in order to prevent the liters/m2, the exact rate depends on the porosity evaporation of solvent. of the prepared soil surface.