Professional Documents
Culture Documents
Test Fire
Test Fire
action should be to
Get a fire extinguisher
Run out of the building
Activate the alarm
Ask your lecturer/boss what to do
Q:3-To operate the fire extinguisher, the acronym P.A.S.S. is often used to
help us remember to ________________.
Pull the pin, aim at the base of the fire, squeeze the handle, and
sweep at the base of the fire
Pass by the fire, activate the fire alarm, select the proper
extinguisher, shoot at the base of the fire
Pull the alarm, alert the response team, shut down the power
sources, secure the area
Pass by the fire, activate the sprinkler system, seal fire area from
oxygen, stop unauthorized entry
Q:9-Switching off the computers and printers at the end of every workday
can prevent any overheating of equipments which in turn lead to fire
hazards
Mark one answer:
True
False
Q:10-What should you do when your clothes catch fire?
Run quickly such that the wind helps to put out the fire
Scream for help
Stop where you are, drop to the floor, roll against the floor and cool
off with water after the fire is out
Grab a fire extinguisher and spray it on your clothes
Q:1-The available fire extinguisher can only be used for a duration of:
30 - 40 seconds
3 - 4 minutes
15 - 20 seconds
1 - 2 hours
20 meters
5 meters
10 meters
3 meters
Q:4-In case of fire we should rescue:
All patients
All staff
Those at immediate danger
All visitors & contractors
RACE
PASS & RACE
PASS
None of the above
Non-Ambulant Patients
Semi-Ambulant Patients
Ambulant Patients
None of the above
Dry Powder
CO2
CO2 & dry powder
Water
Q:3-During a fire emergency, you should close all doors behind you to slow
the spread of a fire.
True
False
Q:4-An exit route consists of three parts: exit access, exit, and exit
discharge.
True
False
Q:6-To operate a fire extinguisher one must pull, aim , squeeze, and
_________ .
Jump
Stand
Sing
Sweep
True
False
True
False
Q:5-During a fire emergency, you should close all doors behind you to slow
the spread of a fire.
True
False
True
False
Q:7-What is the first thing you should do in the case of a fire if you cannot
reach a fire extinguisher?
Raise your hand and ask if you may be excused.
Evacuate the building immediately
Try to find fire extinguisher
All of the above
Q:8-During a fire, if you don't know how to use a fire extinguisher you
should try to figure it out so you can put the fire out.
True
False
4
5
6
7
Q:2-If the fire is growing and might block your way out you should...
Find the nearest fire extinguisher and use it.
Panic and lose track of what is going on.
Evacuate the building immediately.
Call your friends to confirm dinner plans at Winslow.
4
10
1
8
Q:5-In order to put out a fire you should aim the fire extinguisher
Down from above the fire.
At the bottom and circle around the fire.
At the base of the fire and sweep back and forth.
In the middle of the flame.
Q:7-When a fire is too large to fight, on your way out of the building you
should
Run for your life
Make sure your coworkers are also leaving and close doors
behind you as you leave
Open the windows to allow smoke to leave the building
Press the fire alarm and call the fire department