The document provides instructions for removing and installing a throttle body from a vehicle. It lists 5 steps for removal: 1) disconnecting the battery ground cable, 2) removing the intercooler, 3) disconnecting sensors, 4) disconnecting coolant hoses, and 5) removing bolts securing the throttle body to the intake manifold. It notes to always use a new gasket during installation and provides the recommended tightening torque.
The document provides instructions for removing and installing a throttle body from a vehicle. It lists 5 steps for removal: 1) disconnecting the battery ground cable, 2) removing the intercooler, 3) disconnecting sensors, 4) disconnecting coolant hoses, and 5) removing bolts securing the throttle body to the intake manifold. It notes to always use a new gasket during installation and provides the recommended tightening torque.
The document provides instructions for removing and installing a throttle body from a vehicle. It lists 5 steps for removal: 1) disconnecting the battery ground cable, 2) removing the intercooler, 3) disconnecting sensors, 4) disconnecting coolant hoses, and 5) removing bolts securing the throttle body to the intake manifold. It notes to always use a new gasket during installation and provides the recommended tightening torque.
Install in the reverse order of removal. A: REMOVAL 1) Disconnect the ground cable from battery. NOTE: Always use a new gasket. Tightening torque: 8 N·m (0.8 kgf-m, 5.8 ft-lb)
FU-00009
2) Remove the intercooler. <Ref. to IN(STi)-11,
REMOVAL, Intercooler.> FU-01075 3) Disconnect the connector from the throttle posi- tion sensor (A) and manifold absolute pressure sensor (B). (B)
(A)
FU-01073
4) Disconnect the engine coolant hoses from the
throttle body.
FU-01074
5) Remove the bolts which secure the throttle body