Professional Documents
Culture Documents
Procedure:: Designating Components On-the-Fly
Procedure:: Designating Components On-the-Fly
Training Files:
Download the training files using the button below, if you have not done so already.
Download
Procedure Setup:
1. To avoid naming conflicts, it is recommended you save your work, click File > Close until no models
display, then click File > Manage Session > Erase Not Displayed.
2. Click File > Manage Session > Set Working Directory and navigate to the PTCU\CreoParametric2
\Cabling\Designate_On-the-Fly folder and click OK
Figure 1
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017
Designating Components On-the-Fly Page 2 of 6
Figure 2
◾ Click OK.
Figure 3
◾ Click OK.
◾ Click Close .
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017
Designating Components On-the-Fly Page 3 of 6
Figure 4
Figure 5
5. Click OK.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017
Designating Components On-the-Fly Page 4 of 6
Figure 6
Figure 7
2. In the Electrical Parameters dialog box, edit the REF_DES column values, as shown.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017
Designating Components On-the-Fly Page 5 of 6
Figure 8
◾ Click Apply.
3. Enable Entry Ports in the Display For section and expand both connectors and the respective ENTRY
PORTS nodes.
◾ Notice the TYPE and INT_LENGTH values for the Entry Ports.
Figure 9
◾ Click OK.
5. Click Ref Designator Labels from the In Graphics toolbar to enable their display.
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017
Designating Components On-the-Fly Page 6 of 6
Figure 10
http://precisionlms.ecorp.cat.com/precisionlms/standard-content/coach_cp_bcc2716c-be0... 01-11-2017