Actuator-Sensor-Interface: I/O Modules For Operation in The Field (IP 65/67)

You might also like

Download as pdf or txt
Download as pdf or txt
You are on page 1of 2

Actuator-Sensor-Interface

I/O Modules for Operation in the Field (IP 65/67)


Accessories for pneumatic I/O modules
Actuator-Sensor-Interface

■ Overview
All AS-Interface pneumatic For applications in which pneu- These products are not includ- Further details about the repre-
modules are supplied with inte- matic hoses have to be guided ed in the scope of this catalog sentatives of the Legris compa-
grated standard hose plug-in out of the module at an angle or and can be ordered under the ny can be obtained under the
connectors, so that pneumatic if they have to be reduced to a corresponding order number telephone number
hoses can be connected to the different cross-section, a selec- from any representative of the +49 61 05 91 09-0.
module without the need for ad- tion of appropriate products Legris company.
ditional accessories. supplied by Legris can be
found in the diagram below.

Connection of air intake


Possible accessories:
- T plug-in connector 8/8 (e. g. Legris 3188 08 00)
- T plug-in connector 8/10 (e. g. Legris 3188 10 08)

Connection of pneumatic loads


1.2 2.2
Possible accessories:
- Angular plug-in connector 8/8 (e. g. Legris 3182 08 00)
1.4 31 2.4
Connection of control air - Angular plug-in connector 8/6 (e. g. Legris 3182 06 08)
for pressures < 3 bar or vacuum:
- connection via 4 mm hose plug-in connector 24 24

OUT1 1 3 OUT2 1 3
Manual control (momentary/maintained-contact type)
IN1 IN2 - Enables test of pneumatic output
without PLC signal
- One manual control per pneumatic output
IN3 IN4

ASI

Hose, straight connector and plug-in silencer


for exhaust and silencing of compressed air Note on manual control:
Manual control is provided parallel
Possible accessories for variant with hose plug-in to the pilot valve, i. e. switching
connector: is only possible in the normal
- Plug-in silencer (e. g. Legris 0671 08 00) position of the valve.
- Angular plug-in connector (e. g. Legris 3182 08 00)

ASI

IN1

IN2

Power

OUT3 OUT4 Connection of pneumatic loads


Manual control (momentary-contact type)
Possible accessories:
- Enables test of pneumatic outputs
- Angular plug-in connector 8/8 (e. g. Legris 3182 08 00)
without PLC signal
- One manual control per pneumatic output - Angular plug-in connector 8/6 (e. g. Legris 3182 06 08)
- Maintained-contact type manual control with
variant 2I/2OP-VA

Connection for air intake


Possible accessories:
- T plug-in connector 8/8 (e. g. Legris 3188 08 00)
NSA00068

- T plug-in connector 8/10 (e. g. Legris 3188 10 08)

1/84 Siemens NS K · 2002


Actuator-Sensor-Interface
I/O Modules for Operation in the Field (IP 65/67)
Accessories for pneumatic I/O modules

■ Selection and ordering data


Design Order No. Pack This accessory cannot be ordered
via Siemens.
Unit Order from Legris only,
Tel.: +49 61 05 91 09-0,
T plug-in connector for compressed air supply Fax: +49 61 05 91 09-11,
• Hose diameter 10 mm / plug-in part 8 mm Legris 3188 10 08 10 Internet: see 2)

• Hose diameter 8 mm / plug-in part 8 mm Legris 3188 08 00 10

nsa0248

Angular plug-in connector for lateral outputs


• Hose diameter 6 mm / plug-in part 8 mm Legris 3182 06 08 10
• Hose diameter 8 mm / plug-in part 8 mm Legris 3182 08 00 10

nsa0249

Adapter for smaller hoses


• Hose diameter D1/D2 4/8 mm Legris 3166 04 08 10
• Hose diameter D1/D2 6/8 mm Legris 3166 06 08 10

nsa0250

Rings for colour coding of the connections


Hose diameter 8 mm
• White Legris 3110 08 00 100
• Green Legris 3110 08 02 100
nsa0251 • Red Legris 3110 08 03 100
• Blue Legris 3110 08 04 100
• Yellow Legris 3110 08 05 100
Straight connection 1) Legris 3106 08 00 10
Hose diameter 8 mm

nsa0252

Plug-in silencer1) Legris 0671 08 00 10


Hose diameter 8 mm

nsa0253

Polyurethane hose,
black
Bending radius when cold: min. 20 mm
• Hose diameter 4 mm Legris 1025U 04 01 25 m reel
• Hose diameter 6 mm Legris 1025U 06 01 25 m reel
• Hose diameter 8 mm Legris 1025U 08 01 25 m reel
• Hose diameter 10 mm Legris 1025U 10 01 25 m reel
nsa0254

Polyamide hose,
black
Bending radius when cold: min. 55 mm
• Hose diameter 4 mm Legris 1025P 04 01 25 m reel
• Hose diameter 6 mm Legris 1025P 06 01 25 m reel
• Hose diameter 8 mm Legris 1025P 08 01 25 m reel
• Hose diameter 10 mm Legris 1025P 10 01 25 m reel
nsa0254

1) Combination for silenced exhaust air:


Straight connection and plug-in silencer.
2) Further information is available on the Internet at:
http://www.legris.com

Siemens NS K · 2002 Only supplied in packings 1/85

You might also like