T z 7 I z r 7 I i T z I
EE ‘ nanano3 own we Us psy |e =
sate Noro man mevanousne | uOaUBABE — 3“=AANDERAA
A: Reading Ultrasonic Anemometer WN T with PC
Connect the Test Cable to the Anemometer. Connect a 12 Volt Power Supply to the power
cables, the green wire to the positive and the black wire to the negative terminal. Connect the 9-
pin connector to the PC comport. ‘
1) Open HyperTerminal program as shown:
oe 7s one
2) Use Properties button, select actual
comport
x 3) Select Configure and set comport as.
shown:
Faria
| Sv 01m
| Caureyiegen: ie
ns Sse lipo sae
pact | mee
es
seus |i
Bow cores [one“c= AANDERAA
4) Use the following settings,
Serres
OHH O Ds OOM Seen. cte
|
5) and the following ASCII setup.
Poe
ASCII Sending .
‘Send ine ends with ine feeds
Echo typed character lacaly
ne dey: [2 nitencord
Gharacter delay: [20] mitseconds.
ASC Receing
C bppend line feeds to: Inoomingine ende
Di force incoming data to 768 ASC
‘op ines that exceed teal with
6). Close the setup windows by clicking OK back to start window. Click the Connect
button and data from the sensor should be shown as below.
eee
ee a ten Dest
Use a big Fan to blow on the sensor to have values other than zero. ‘The data will be updated
with 2-3 seconds interval.