This document provides inspection instructions for the transfer system in various Toyota vehicle models. It describes how to check the 4LO and center differential lock indicator lights by turning the ignition on, shifting to neutral, and toggling the transfer position switch. The lights should illuminate normally, otherwise issues may exist with the switch, transfer control ECU, actuator, CAN communication, or combination meter and those systems should be inspected.
This document provides inspection instructions for the transfer system in various Toyota vehicle models. It describes how to check the 4LO and center differential lock indicator lights by turning the ignition on, shifting to neutral, and toggling the transfer position switch. The lights should illuminate normally, otherwise issues may exist with the switch, transfer control ECU, actuator, CAN communication, or combination meter and those systems should be inspected.
This document provides inspection instructions for the transfer system in various Toyota vehicle models. It describes how to check the 4LO and center differential lock indicator lights by turning the ignition on, shifting to neutral, and toggling the transfer position switch. The lights should illuminate normally, otherwise issues may exist with the switch, transfer control ECU, actuator, CAN communication, or combination meter and those systems should be inspected.
Engine / Hybrid System Drivetrain 1. INSPECT INDICATOR LIGHT A343F AUTOMATIC TRANSMISSION / TRANSAXLE a. 4LO Indicator Light: A750F AUTOMATIC TRANSMISSION / TRANSAXLE i. Turn the ignition switch to ON. CLUTCH ii. Move the shift lever to N (vehicle is stopped). G52F MANUAL TRANSMISSION / TRANSAXLE iii. for 1GR-FE, 1KD-FTV: R150F MANUAL TRANSMISSION / Change the transfer position switch from H4 to L4. TRANSAXLE RA61F MANUAL TRANSMISSION / iv. for 2TR-FE, 5L-E: TRANSAXLE Change the transfer position switch from H4L to L4L. VF4BM TRANSFER / 4WD / AWD TRANSFER SYSTEM v. Check the 4LO indicator light. PRECAUTION OK PARTS LOCATION SYSTEM DIAGRAM 4LO indicator light comes on or 4LO indicator light comes on after blinking. PROBLEM SYMPTOMS TABLE If the result is not as specified, inspect the switch, 4 wheel drive control ECU and transfer shift actuator assembly. TERMINALS OF ECU If the system is normal, there may be a malfunction in the CAN communication system or combination meter. In this case, first check INSPECTION the CAN communication system Click here. Then check the combination meter Click here. 2013-08 - 2014-08 b. Center Differential Lock Indicator Light: 2014-08 i. Turn the ignition switch to ON. TRANSFER OIL TRANSFER CASE FRONT OIL SEAL ii. for 1GR-FE, 1KD-FTV: TRANSFER CASE REAR OIL SEAL Change the center differential lock switch from Free to Lock. TRANSFER ASSEMBLY iii. for 2TR-FE, 5L-E: CENTER DIFFERENTIAL LOCK Change the transfer position switch from H4F to H4L. SWITCH (w/ Combination Switch) CENTER DIFFERENTIAL LOCK iv. Check the center differential lock indicator light. SWITCH (w/o Combination Switch) OK 4WD CONTROL SWITCH (w/