Professional Documents
Culture Documents
K-Mix CC Message
K-Mix CC Message
As stated in the previous section, 4.3.3.1 – MIDI Channel, each input channel’s MIDI controllable
parameters are separated by MIDI channel; sending messages on MIDI channel 1 will control input
channel 1, MIDI channel 2 will control input channel 2, and so on. This is nice because the CC number
for each parameter (such as EQ High Frequency) can remain the same, just change the MIDI channel.
The following list details the parameters that may be controlled, and the MIDI CCs that are used to
control them.
External MIDI messages for controlling Mains panning, Aux 1–3 panning, and
Aux 1–3 send levels will be ignored when surround panning is enabled; these
parameters are not accessible when using surround.
77
K-M IX H ARDWARE
External MIDI messages for controlling the main output bus’ EQ, Gate, and
Compressor parameters will be ignored when surround panning is enabled; these
parameters are not accessible when using surround — the effects are bypassed.
78
K-M IX H ARDWARE
The following list details the parameters that may be controlled and the MIDI CCs that are used to
control them.
External MIDI messages for controlling Aux 1–3 output levels and mutes will be
ignored when surround panning is enabled; these parameters are not accessible
when using surround.
External MIDI messages for controlling Surround parameters will be ignored when
stereo panning is enabled; these parameters are only accessible when using
surround.
• Reverb Channel Send Levels 1–8 = CCs 1–8 • Surround Panner 3 Angle = CC 19
• Reverb PreDelay = CC 9 • Surround Panner 3 Radius = CC 20
79