Professional Documents
Culture Documents
KM15 Pressure Transmitter: Liquid And/or Gas Measurement Interface With Stainless Diaphragm
KM15 Pressure Transmitter: Liquid And/or Gas Measurement Interface With Stainless Diaphragm
B01-35-E
Outline
KM15 is a pressure transmitter using a "vapor
deposition semiconductor strain gauge type
sensor" which is widely used in various industrial
applications. Since the pressure sensor is welded
to the fitting, durability is excellent.
(Only available for Lot production)
Features
・Wide Temperature Capability
・All-welded pressure construction
・High EMI/RFI rating
・Applicable to a wide range of applications from
low pressure to high pressure
RoHS
・IP 65 Ingress rating
Features of sensor
Sensor
Condition A small sale Lot production
Specifications
Pressure range 3.5 MPa and under Pressure range 5 MPa and over
Compensated temp.
Environmental -20 to 70℃ -30 to 120℃ (Except cable type are -30 to 105℃)
range
performance
Operating temp.range -20 to 70℃ -40 to 120℃ (Except cable type are -30 to 105℃)
Storage temp.range -30 to 80℃ -40 to 140℃ (Except cable type are -40 to 120℃)
Standard: 500m/s2 (11ms or less, X, Y, Z 3 times for each at constant temp.)
Shock proof
Option: 1000m/s2 (6ms or less, X, Y, Z 3 times for each at constant temp.)
Standard: 150m/s2 (20 to 400Hz, X: 4h, Y: 2h, Z: 2h at constant temp.)
Vibration proof
Option: 300m/s2 (20 to 1000Hz, X: 4h, Y: 2h, Z: 2h at constant temp.)
Durability More than 10,000,000 times. (10 to 100%F.S.)
Protection IP65 (For the connector direct type, with mating connector connected.
For cable type and lead type, body section only. Harness end is excluded.)
Diaphragm SUS630 (17-4PH) welded to a fitting
Material Fitting SUS304
Case SUS304
7/16-20UNF flared 37° , 7/16-20UNF flared 45° Maximum pressure range: 5MPa
R1/8, R1/4, R3/8, G1/4A*3, G3/8A,
Fittings 1/8NPT, 1/4NPT,
G1/4A DIN3852 Form A, G1/4A DIN3852 Form E, Maximum pressure range: 50MPa
7/16-20UNF-2A SAE J1926-2*3,
9/16-18UNF-2A SAE J1926-2
Connector direct type HW090, EJⅡ (+), METRI-PACK 150, M12x1 (4pin), Deutsche DT04-3P
Flying leads 0.3m (Standard)
Lead type Econoseal J series〈MARK Ⅱ (+)〉
Terminations (Tyco Electronics Japan G.K.)
Shielded cable 1m (Standard)
Shielded cable type Econoseal J series〈MARK Ⅱ (+)〉
(Tyco Electronics Japan G.K.)
Approx. 60g (Connector direct type, R1/4)
Weight
Approx. 110g (Cable type, R1/4)
Applicable Directive: 2004/108/EC
CE marking Applicable Standards: EN61326-2-3:2006
*Please connect supply of electric power net that doesn't receive the influence of the excess voltage by the thunder.
*1 Units of psi and bar are also produced. It is limited to applications are defined in the Measurement Law.
For more information, please contact us.
*2 Including the right to accuracy. ①Linearity ②Hysteresis ③Repeatability
*3 G1/4A、7/16-20UNF-2A SAE J1926-2 screws, if more than 10MPa range, fitting material is SUS416.
2
KM15
Pressure Transmitter
Dimensions 1 Unit: mm
3 2 1
Model number: 6189-0131
2
Common
(Sumitomo Wiring Systems)
1
Output (+)
Power (+) Power (+)
(φ25) (φ25)
(19)
(17)
(63.5)*1
(61.5)*1
Label
Label
14*1 7*1
14*1 7*1
R1/4 R1/4
φ1 φ1
9 9
9
9
17 Hex. 17 Hex.
KM15-17□ KM15-57□
M12×1 Connector(4pin)
M12×1Connector (4pin)
Power (+)
(φ25)
(15)
(59.5)*1
Label
*1
7
*1
14
R1/4
19
9
17 Hex.
*1 Case of R1/4
For other fittings, please refer Dimensions 3.
KM15-M7 □
3
KM15
Pressure Transmitter
Dimensions 2 Unit: mm
(32.5)
(26)
(70.5)*1
*1
(77)
Label Label
*1
*1
7
7
*1
*1
14
14
R1/4 R1/4
φ1
19 9
9
9
17 Hex. 17 Hex.
KM15-87□ KM15-47□
(Black)
Power (+) Output (+)
(Red) (White) Econoseal J series
Common (23.1) 〈MARK Ⅱ (+)〉
(Tyco Electronics Japan G.K.)
(Black)
(13.9)
Terminal: Sn plate
(32.5)
Model number: 2822390-1 *Be careful not to apply the like water
to the tube for the air release.
Housing
(18.5)
(φ20)
(φ25) (φ25)
(75)
Label Label
*1
(49)
14*1 7*1
*1
7
*1
14
R1/4 R1/4
19 19
9
17 Hex. 17 Hex.
KM15-2 7□ KM15-3 7□
*The drain line is not
grounded to the case.
4
KM15
Pressure Transmitter
Dimensions 3 Unit: mm
Fitting
KM15-□4□ KM15-□5□ KM15-□6□ KM15-□7□ KM15-□8□
Hex. height
Hex. height
Hex. height
throttle throttle throttle throttle
7
11
7
7
13.5
14
10
45
14
15
°
φ4.9 φ5.5
7/16-20UNF φ9.25 7/16-20UNF φ9.2 R1/8 R1/4 R3/8
flared 37° flared Throttle φ0.7 Throttle φ0.7
SAE J514 Tightening torque Tightening torque
6N・m 6N・m
11.5
9 9 9 9
9
9
9
φ1 φ1 φ1 φ1 4.3
φ2
17 Hex. 17 Hex. 17 Hex. 17 Hex. 22 Hex.
Maximum pressure range: 5MPa (50bar, 750psi) Maximum pressure range: 50MPa (500bar, 7500psi)
Hex. height
Hex. height
Hex. height
φ14±0.1
7
φ11±0.1 Marking of NPT
9.5
7
10
14.5
2.7
16
2.7
12
1/8NPT
O-ring O-ring
P11 1
*
* 1/4NPT
Throttle φ0.7 P14 2 Throttle φ0.7 Throttle φ0.7
G1/4A Tightening torque NBR Tightening torque Tightening torque
6N・m G3/8A 6N・m 6N・m
10
11.5
1 9
φ2 φ1
9
9
4.3 φ1
φ2
19 Hex. 22 Hex. 17 Hex. 17 Hex.
* *
1 JIS B 2401 Class 1 B NBR 2 JIS B 2401 Class 1 B NBR
Without With
Hex. height
Hex. height
Hex. height
2.05±0.15
2.3±0.5
2.3±0.5
+0.05
throttle throttle throttle throttle φ9.25 -0.08 throttle throttle
+0.2
+0.2
9.5
11
11
0
+0.05
11
φ12.24 -0.08
2
11±0.2
3
3
12±0.2
12
12
11.5
1
10
Units of psi and bar are also produced. It is limited to applications are defined in the Measurement Law.
Introduction of option
5
KM15
Pressure Transmitter
Model number configuration Please specify the model number, each specs and the range for ordering.
Model
K M 1 5
Pressure transmitter ① ② ③ ④ ⑤ ⑥ ⑦ ⑧ ⑨ ⑩ ⑪ ⑫ ⑬ ⑭ ⑮
Model number Selective spec. Additional spec. (Option)
① 1 Connector direct type HW090 Sealed pressure type (Pressure range: 1MPa and over)
Type 2 Lead type (0.3m Standard) Sealed pressure type (Pressure range: 1MPa and over)
3 Shielded cable type (1m Standard) Gauge pressure type
4 Connector direct type Deutsche DT04-3P Sealed pressure type (Pressure range: 1MPa and over)
5 Connector direct type EJⅡ (+) Sealed pressure type (Pressure range: 1MPa and over)
8 Connector direct type METRI-PACK 150 Sealed pressure type (Pressure range: 1MPa and over)
M Connector direct type M12x1 (4pin) Sealed pressure type (Pressure range: 1MPa and over)