The document provides requirements for brazing fabrication. It states that surfaces to be brazed must be clean and free of contaminants. After brazing, joints must be cleaned of flux residue before inspection. Any post-brazing operations like heat treatments must follow a qualified procedure. Defective brazed joints can be rebrazed if thoroughly cleaned and the same brazing procedure is used; otherwise, a new repair procedure must be established and qualified.
The document provides requirements for brazing fabrication. It states that surfaces to be brazed must be clean and free of contaminants. After brazing, joints must be cleaned of flux residue before inspection. Any post-brazing operations like heat treatments must follow a qualified procedure. Defective brazed joints can be rebrazed if thoroughly cleaned and the same brazing procedure is used; otherwise, a new repair procedure must be established and qualified.
The document provides requirements for brazing fabrication. It states that surfaces to be brazed must be clean and free of contaminants. After brazing, joints must be cleaned of flux residue before inspection. Any post-brazing operations like heat treatments must follow a qualified procedure. Defective brazed joints can be rebrazed if thoroughly cleaned and the same brazing procedure is used; otherwise, a new repair procedure must be established and qualified.
HB-1400 CLEANING OF SURFACES TO BE thermal treatments shall be performed in accordance
BRAZED with the qualified procedure. The surfaces to be brazed shall be clean and free from grease, paint, oxides, scale, and foreign matter HB-1402 REPAIR OF DEFECTIVE BRAZING of any kind. Any chemical or mechanical cleaning method may be used that will provide a surface suitable Brazed joints which have been found to be defective for brazing. may be rebrazed, where feasible, after thorough clean- ing, and by employing the same brazing procedure used for the original braze. If a different brazing HB-1401 POSTBRAZING OPERATIONS procedure is employed, i.e., torch repair of furnace brazed parts, a repair brazing procedure shall be estab- Brazed joints shall be thoroughly cleaned of flux lished and qualified. residue by any suitable means after brazing and prior When a repair brazing procedure is established it to inspection.1 Other postbrazing operations such as shall provide control of the application of brazing filler metal to meet the conditions set forth in HB-1301(a). 1 Flux residues can be extremely corrosive as well as interfere with Where these requirements cannot be met, the limitations visual inspection. of HB-1301(b) will apply.