Professional Documents
Culture Documents
PAPER-II (JUNE 2016) : B) Photoelectric Cell
PAPER-II (JUNE 2016) : B) Photoelectric Cell
1) Smoke in the cargo and baggage compartment of an aircraft is commonly detected by which
of the following detection method
a) Chemical reactor.
b) Photoelectric cell .
c) Sniffer.
2) A metal which can be hammered, rolled or pressed into various shapes without cracking,
breaking or leaving some other detrimental effect
a) Ductility.
b) Malleability.
c) Elasticity .
d) Toughness.
3) Austenite is
a) At elevated temperature, the carbon is dissolved in iron matrix in the form of a solid
solution.
b) Carbon particle precipitates as a cloud of very fine carbide particle is called austenite.
c) Carbon in steel exists in the form of particle of iron carbide.
8) Sensitivity of coil is 20000 ohm/volt the amount of current required for full scale deflection
is
a) 5 milli amphere.
b) 5 micro amphere.
c) 30 amphere.
10) Integrated drive generator employ a type of high output AC generator that utilizes.
a) A brushless system to produce current.
b) Brushed and slip rings to carry generated DC exciter current to the rotating field.
c) Battery current to excite the field.
22) If three landing lights of 20watts are connected to a 12v aircraft system the total current
will be
a) 20 amphere
b) 3 amphere
c) 5.5 amphere
d) 5 amphere
24) Metal used to make stringers, bulkheads, wing skin, formers, etc is
a) Wrought aluminum alloy
b) Casting aluminum alloy
c) Permanent mold aluminum alloy
29) In a NPN transistor application, the solid state device is turned on when
a) Emitter is positive with respect to the base
b) Base is negative with respect to the emitter
c) Base is positive with respect to the emitter
30) Find the decimal equivalent for the binary number 10110101
a) 121
b) 181
c) 254
d) 264
31) (1) An airspeed indicator measures the differential between pitot and static air pressure
surrounding the aircraft at any moment of flight
(2) An airspeed indicator measures the differential between pitot and cabin air pressure at
any moment of flight.
a) Both (1) and (2) are correct.
b) Only (1) is correct.
c) Only (2) is correct.
34) If a rigid tube is too short for the flare to seat before tightening, pulling it into the place
before tightening
a) May distort the flare
b) May distort the sleeve and nut
c) May distort the angle of flare
35) Which instrument is used for measuring high range ohm-meter value
a) Megohmeter
b) Milliammeter
c) Micrometer
37) The Dzus turnlock fastener consist of a stud grommet and a receptacle, in this stud length is
measured in
a) Hundreds of an inch
b) 1/16th of an inch
c) 3/8th of an inch
38) Which instrument are connected to an aircraft static pressure system only
a) Vertical speed indicator and altimeter
b) Airspeed indicator and vertical speed indicator
c) Magnetic compass indicator and directional deviation indicator
39) The angle at which the twist drill should make with soft metal is
a) 180 degree
b) 118 degree
c) 59 degree
d) 90 degree
44) The type of corrosion along the grain boundaries of an alloy commonly results from a lack
of uniformity in the alloy structure
a) Intergranular corrosion
b) Stress corrosion
c) Filliform corrosion
d) Galvanic corrosion
45) The metal which have excellent bend ability and bend ductility but vulnerable to
contamination is
a) Titanium beta
b) Titanium alpha
c) Combined titanium alpha and beta
50) If a generator is equipped with a vibrator type voltage regulator, the actual time the
voltage regulator points remain open
a) Depends on the load carried by the generator
b) Is increased when the external load is greater than the generator output
c) Is controlled by the reverse current cutout relay point clearance
51) Large indentation in metal which are necessary to start a twist drill are made with
a) Centre punch
b) Drift punch
c) Starting punch
54) The rivets which are to be driven within specified time interval is termed as
a) Ice box rivets
b) Self plugging rivets
c) Wiredraw cherry lock rivets
61) Rivnut is
a) Hollow blind rivet
b) Solid shank rivet
c) Deutch rivet
d) Dill lock rivet
62) The eight bit register that stores the memory output when a memory read operation is
performed
a) MDR
b) MAR
c) MCR
d) MDD
64) The corrosion which is usually visible as pitting and which is often referred to as dissimilar
metal corrosion is termed as
a) Galvanic corrosion
b) Filliform corrosion
c) Intergranular corrosion
65) The drawing which shows the ideal or perfect size of measurement is
a) Dimension
b) Tolerance
c) Allowance
67) When a flexible hose has been repaired then it should be ----------------------before
installation
a) Pressure tested to at least 1.5 times the system pressure
b) Pressure tested to at least 2.5 times the system pressure
c) Pressure tested to at least 1.5 times the system pressure and holding the pressure for
ten minutes