Download as pdf or txt
Download as pdf or txt
You are on page 1of 18

Quick Start Guide

Aircraft Diagram
OBTAIN is a foldable quadcopter with a stable camera and flexible flight
characteristics.
With this quadcopter you are able to:
•With its 5 Megapixel camera you can take photos and record Full High Definition
video at 1080P. It's so easy to capture a complicated shot.
•The maximum flight speed is approximately 43 km/h. (27 miles per hour)
•Hover time 23 minutes.

② ③



⑥ ⑦

① Drone Head Indicator Light ⑥Micro USB


②Propeller ⑦Frequency button
③Gimbal ⑧Motor
④Power Switch ⑨Intelligent Battery
⑤Drone Status Indicator Light
Remote Controller Diagram

① ①


③ ④

⑤ ⑥ ⑤

⑧ ⑨

1.Antennas
2.Mobile Device Support
3.Flight Mode Switch
4.Channel Reservation
5.Control Stick
6.Indicator Light

7.Power Switch
8.Take off / Landing Switch
9.Video / Photo Switch
10.Gimbal Adjustment 11

11.Mobile Device Support


12 13
Extension Button
14
12.Channel Reservation
13.Return to Home Switch
14.USB Charging Port
Gimbal Diagram
Gimbal Specification:

① Camera

SD card Slot ②

The 3-Axis gimbal can turn in three directions to make filming and
shooting pictures easier:

Pitch:-90°~0° Yaw:-45°~45°

Roll:-30°~30°
Preparation before flight
Prepare the Battery
1.Check the battery level of the aircraft

Check battery level

Power indicator Light

LOW FULL

2.Charge the Batteries of the aircraft

Power
outlet

Adapter Charger

Green light flashing


(stand by)

Red Normally on
(charging)

Green Normally on
(charge complete)

Make sure the battery is charged full when you use the battery for the
first time. Please check the battery power of the battery button for
checking the current battery level.
3.Charging the Batteries of Remote controller

Indicator
Light

Red Light Normally on(On Charging)


Green Light Normally on( Charge Complete)

Micro USB

Please put the battery into remote controller before charging.


The Indicator light shows Green when is charge complete.

Preparation aircraft
All the arms of the aircraft are fold up on delivery, as shown below:
1. Firstly, please open the front arms, as shown below:
2. Secondly, rotate the back arms 180° to make the propeller come up
as shown

180°

3. After that spread the arms 60°, as shown below:

60°

· FIRSTLY open the front arms before the back arms.


• You have to rotate the back arms 180°, then spread the back
arms 60° to the outside.
4. Spread the propellers as shown below:
Prepare Remote Controller
In this section you will find how to open the mobile device support and to
adjust the antennas.

Expand the antennas Rotate the antennas,


outward, like is shown above. as shown above.

Adjust the antennas to 45° with


the remote control and expand Put the battery into the
the mobile device support as back slot of the remote
shown above. control, like shown above.

Put the mobile device in the


mobile device support like this.

Please use your mobile device to connect C-Fly APP for checking the
Real-Time Transmission, And enjoy your flying ,Photo /Video and so on.

10
Prepare Gimbal
1.Remove the gimbal cover and gimbal clamp from the camera as
shown below:

· The Gimbal cover for protective the Gimbal.


• Please install the Gimbal cover after finish your flight.

2. Insert the Micro SD Card in the SD Card Slot.

SD

· Do not remove the Micro SD card from the OBTAIN when the
aircraft is turned on.
• To ensure the stability of the camera system, video files will be of
the duration of 30 minutes per file.
Flight
1. Insert the battery inside the aircraft's battery slot.

2. Put the aircraft on a flat surface.

3.Turn on OBTAIN Remote Controller


a.Before Turn on the remote controller, please switch the “ Flight Mode”
to “A Mode”“Return switch”,”Channel Reserved” to be remain closed.

Switch to Channel
“A Mode” Reserved OFF
OFF

OFF OFF
ON

S ON ON
P
A

Channel Return
Reserved OFF Home OFF
b.Please make sure all the switch is turn off. After turn on the switch of controller.
The controller will show Green Light.

Indicator light shows Green.

4.Turn on the power of the aircraft.

To switch on the OBTAIN


Short-press and then
Long-Press the power button
2s to switch off, follow the
same process.

Turn on the power of the Remote controller and then turn on the power
of the aircraft.

5.Connect GPS Signal


a. Wait for the "aircraft status indicator" to show that the green light is always on,
when the aircraft is connected to the GPS signal to locate the return point.
b . Switch the aircraft mode to P mode, and the aircraft can take off safely and
other operations

S
P
A

Aircraft green light is always on Switch to P mode


6.Start Your Flight Experience
a.Suggest you operation like below shown:

You can start the flight manually, like shown: Or Turn off the aircraft manually, like shown:

Take Off, like shown: Landing, like shown:

Long-press “Take off/ Landing switch” on the remote for 3S, The sounds of
remote Bi-Bi-Bi, The aircraft will automatically take off to 1.2meters.

1.2m

7.After the OBTAIN starts to fly, you can control the aircraft with the control
sticks, also can through the button of “ Photo/Video” for shooting.

Left joystick Throttle/Up Forward Right joystick

Left Right
sideways sideways
Fly Fly

Left yaw Right yaw

Throttle down Backward

Short-press for photo, Long-Press 2-3s for video, when on Video,


you also can take a photo.

Moving the throttle up and the pitch forward at the same time,
will make the aircraft fly forward very fast.
Return to Home Function
If the OBTAIN flies away or in an unknown direction, you can switch on the
Return to Home-function. Just wait for the aircraft to come back. When the
aircraft is landing, you can use the rubber controls to land in a safe place.

OFF
Forward Right joystick

ON

Left Right
sideways Fly sideways Fly

Backward

When the OBTAIN has lost the signal of the remote control. It will
automatically return to the take off place.
When the OBTAIN has a low battery, it will automatically return to
the take off place.
When In the process of return, The left joystick can not control.

After landing on the ground, the motor automatically stops running.


Waiting for the wing to stop spinning completely.
Turn off the aircraft power (short-press and long-press for 2S), then
close the remote control and finish the flight.

Turn off the aircraft power Turn off the remote power

Please turn off the aircraft power, and then turn off the remote power.
Flight mode
A-mode:Altitude Hold Mode:
When you choose A-mode, you will be
able to fly the OBTAIN manually. S
P
Though you still will have altitude hold A
activated. The GPS Location Mode will
not be available.

P-mode:GPS Location Mode:


When you choose P-mode, you will be
able to fly by the GPS signal,the position S
of the OBTAIN will be automatically P
A
adjusted by the GPS-signal.

In flight mode P, the aircraft should get a stable GPS signal to be


able to fly.

S-mode: Flight around one point:


When you choose S-mode, the OBTAIN will fly around one point
automatically. By moving the right stick of the remote control backward,
you widen the circle radius. The operation is shown below:

S
P
A

After selecting S-mode, the quadcopter rotates automatically.

Forward Right joystick

Backward

By moving the right stick of the remote control up or down, you can
decide de measure of the radius of the circle.
Fly Safe
Flight safety conditions

120m

Fly in Open Strong GPS Maintain Line Fly Below


Areas Signal of Sight 400 feet(120m)

Threats to flight precautions

Avoid flying over or near obstacles, corwds, high voltage power lines, trees
or bodies of water.
DO NOT fly near strong electronmagnetic sources such as power lines and
base stations it may affect the onboard compass.

No flying environment

≥10m

DO NOT use the aircraft adverse weather conditions such as


rain,snow,fog and wind speeds exceeding 10 m/s( 22mph)

Stay away from the rotating propellers and motors.


Indicator Light of Aircraft
Drone Head
Indicator Light

Drone Head
Drone Status Indicator Light
Indicator Light Indicator Light

The front LED lights on the aircraft show the flight direction of the
quadcopter. When the power is switched on the lights will be solid Green.
The back LED light of the aircraft show the flight status, please read the
below table to understand the different colors of the back light.

OBTAIN flight status indicator light explanation:


Normal Flight Status Information:
Light Color Indicator Status description
Solid blue light System Self-Test.
Solid green light GPS position is locked.
Flashing green light GPS position is not locked.
GPS position cannot be locked.
Green light flashing twice Use visual location system.
Blue light flashing twice Remote control is connected.
Compass must be horizontally
The light is flashing
calibrated. After calibration lights
blue and red will be normal.
The light is flashing Compass must be vertically
red and green calibrated. After calibration lights
will be normal
Warning Status Information:
Light Color Indicator Status description
Flashing blue light Remote control is not connected.
Solid red light Serious system fault.
Red light flashing twice Serious low-voltage alarm.
Flashing red light Low-voltage alarm.
The light is flashing Compass data error: compass
blue and green needs to be calibrated
Indicator Light of Remote
Indicator light state of Remote when Running
Light Color Indicator Prompt tone Status description
Solid red light None Serious Mistake
Flashing Low voltage alarm, need charging
red light Bi-Bi-Bi
or reset Joystick
Red light Low battery Power, remote will be
flashing twice BiBi-BiBi-BiBi closed after sounds and flashing

Solid green light None Remote controller Normally


Green light Remote control Turn on, without
flashing twice BB-BB-BB any operating within 3s. It will
disappear when you operating
Flashing
green light B-B-B Return to home Mode
The light is flashing None Joystick Calibration
red and green
Charging when remote turn off
Light Color Indicator Status description
Solid red light charging
Solid green light charge complete

Download Mobile Device Application


Scan the below QR-Code to download the OBTAIN Mobile Device
Application for your phone

Android IOS

More information on OBTAIN and all our other products you will find on:
http://www.cfly-cn.com
www.cfly-cn.com

You might also like