Professional Documents
Culture Documents
Engine+immobilizer A19 PDF
Engine+immobilizer A19 PDF
32
GENERAL INFORMATION
ENGINE IMMOBILIZER
Description
32
MUTE
MODE
+ VOL -
SEEK
3
4
STORAGE BOX
ON S
CC T
A
AR
LOCK
1
T
RA19320010
The vehicle is equipped with engine immobilizer system. The anti-theft features of vehicle have improved due
to the integration technology of ignition key identification and engine start-up. When the engine is started with
unprogrammed ignition key, the engine immobilizer sends the detected signal to the engine control module
and the engine control module outputs the prohibit starting command, thus effectively reduces the possibility
of being stolen.
Operation
When the ignition key is inserted into the ignition switch, the immobilizer coil can detect the data information of
the ignition key, and sends the data information to the immobilizer control module. The immobilizer control
module communicates with the engine control module (ECM) via CAN BUS system, realizing codes
verification and mutual certification. The battery and ignition switch supply power to the immobilizer control
module continuously, allowing the immobilizer to save the trigger memory that has been generated and the
malfunctioning content.
Circuit Diagram
IGNITION SWITCH
ON OR START
INSTRUMENT
RF04 PANEL FUSE
10A AND RELAY BOX
I-005
4
32 IMMOBILIZER
R
COIL
Br
W
4 B1 B2 B3
IG-SW ANT A ANT B GND IMMOBILIZER
CONTROL
MODULE
CAN-H CAN-L GND I-032
6 8 2
G
I-004
11 25
G
I-026
B-053
G
14 6
17 1 DATA LINK
CONNECTOR
ECM I-013
B-001
1 2 3 4 5 6 7 8 9 10 11 12
13 14 15 16 17 18 19 20 21 22 23 24
29 30 31 32 33 34 35 36 37 38 39 40 41 42 1 3 5 7
25 26
15 16 17 18 19 20 21 22 23 24 25 26 27 28 2 4 6 8
87
85 86 86 86 1 2 3 4 5 6 7 8 9 10 11 12 13 14
87 30 87 30
30 85 85
I-032
I-005 I-004 W
B L
16 15 14 13 12 11 10 9 8 7 6 5 4 3 2 1
16 15 14 13 12 11 10 9
32 31 30 29 28 27 26 25 24 23 22 21 20 19 18 17 B1 B2 B3
8 7 6 5 4 3 2 1
48 47 46 45 44 43 42 41 40 39 38 37 36 35 34 33
64 63 62 61 60 59 58 57 56 55 54 53 52 51 50 49 IMMOBILIZER COIL
I-013
B
B-001
B
EA19320010
ON-VEHICLE SERVICE
Immobilizer Control Module
Removal
1. Turn off all the electrical devices and ignition switch.
2. Disconnect the negative battery cable.
3. Remove the left lower instrument panel protector assembly (See page 43-16).
4. Disconnect the connectors (arrow) and remove the fixing
bolt (1) of immobilizer control module with a wrench.
32
1
RA19320020
Installation
Installation is in the reverse order of removal.
CAUTION