This engineering estimate is for the fabrication of a 1 unit rotating jig weld with a maximum capacity of 16 tons and motor-driven system. The estimate includes the costs for mechanical and electrical systems such as an 11kW 3-phase motor, gear box, bearings, pulleys, couplings, and an electrical control panel. The total cost for these materials and labor is not specified.
This engineering estimate is for the fabrication of a 1 unit rotating jig weld with a maximum capacity of 16 tons and motor-driven system. The estimate includes the costs for mechanical and electrical systems such as an 11kW 3-phase motor, gear box, bearings, pulleys, couplings, and an electrical control panel. The total cost for these materials and labor is not specified.
This engineering estimate is for the fabrication of a 1 unit rotating jig weld with a maximum capacity of 16 tons and motor-driven system. The estimate includes the costs for mechanical and electrical systems such as an 11kW 3-phase motor, gear box, bearings, pulleys, couplings, and an electrical control panel. The total cost for these materials and labor is not specified.
PEMBUATAN 1 UNIT ROTATING JIG WELD (CAPACITY MAX:16 TON) DENGAN SISTEM PENGGERAK MOTOR
Harga Satuan ( IDR) Jumlah Harga (IDR)
NO Uraian Pekerjaan Volume / Length Tonase Material Jasa Material I PEKERJAAN MECHANICAL & ELECTRICAL A Sistem Transmisi Deskripsi Qty 11 KW- 3-Phase - 8 Pole 750 Rpm , with bore 1 Motor AC 3-Phase 4 mm gr diameter: 45 mm
2 Gear Box WPA Worm Gear Ratio (1:60) , Sizes: 175 4 mm gr
Pillow Block bearing FYH type UCP 213;
3 Bearing 8 mm gr with ᴓ 65 mm
Include Lagging rubber ( D drum= 10 inch &
Thickness drum = 0,811 inch , Thickness 4 Pulley 4 mm gr Lagging= 12 mm, D shaft= 65 mm , Panjang drum = 300 mm ) Type FCL-250 ; with ᴓ Luar = 250 mm ᴓ Max Bore = 71 mm 5 Coupling ᴓ Dalam = 125 mm 4 mm gr ᴓ Ready bore = 20 mm
Type FCL-250 ; with ᴓ Luar = 250 mm
ᴓ Max Bore = 71 mm 6 Coupling ᴓ Dalam = 125 mm 4 mm gr ᴓ Ready bore = 20 mm